2005 Ford Escape: problems, recalls and reliability
5 recalls and 1,584 owner complaints on record; the weakest area is structure (20% of complaints); the 2003 and 2004 and 2006 and 2007 model years look more trouble-free.
Data updated weekly · latest recall Sep 2015
All counts are reports filed with NHTSA in the United States - US market only, not worldwide totals.
Common problems
Computed from 1,584 owner complaints filed with NHTSA for this exact model year.
“I bought a 2005 Ford escape the VIN number on the dash and the title do match however the ECU and the door jamb VIN [XXX] which is for a 2006 Ford escape 4 cylinder 2.3. the vehicle I bought should be a 6 cylinder with a 3.0 l the mechanic says mismatched VIN the dealership refuses to listen. About the vehicle on [XXX] drove it 30 miles then was able to call the mechanic for some maintenance as his car was for my daughter and that is when I got to bad news of a mismatched VIN. Not even your odometer reading is correct has less on it now than it did back in 2018 and it's documented as accurate. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)”Owner report · Unknown Or Other · Dec 2025
“Front Subframe rusted out causing loss of steering and control. Car came to a complete skidded stop . The front wheel nearly came off. The subframe issue is the same problem that resulted in a recall of the 2001-2004 Ford Escape.”Owner report · Unknown Or Other · Dec 2024
“The right lower control arm separated from the subframe due to subframe rust. It caused loss of handling and rendered the car immobile. It was caused by a panic stop at a low speed. The car was towed to an independent garage where it is awaiting repair. Parts affected were the subframe, CV axle joint and the front fender (From the wheel hitting it when it broke).”Owner report · Suspension · Mar 2024
Show 7 more owner reports
“Hello, The engine cradle subframe on my 2005 Ford Escape has completely rusted through on the right hand side where it attaches to the steering control arm. As I was driving the subframe broke which made it impossible to steer the car. This pulled my car off the road to the passenger side. Fortunately I was not injured. Having now researched this issue, it is a common problem with 2005 Ford Escapes. This is very dangerous, and it should be addressed as it creates a life threatening situation.”Owner report · Structure · Jun 2023
“Stalled out while driving down hwy. At 70 mph. Cars swirved and I almost got hit from behind due to my vehicle just cutting out. No warning lights came on it just shut off battery light n engine light then came on after vehicle lost power and I had to get off road without causing an accident which almost occurred due to the speed and area I was driving at time vehicle cut out I still have not figured out why it just cut out. Very dangerous all around.”Owner report · Fuel/Propulsion System · May 2023
“My rear passenger side rusted right out completely and the strut mount is not attached to any part of the body. It caused my vehicle to swirve off the road almost hitting another vehicle when it was raining out also in the snow this occurred several times where my rear end jerked sideways pulling my truck into a complete circle.”Owner report · Structure · Apr 2023
“I was heading back to Louisville Ky from bowling green Ky when my suv started to slow down and started running rough and check engine light flashed then stayed on I pulled off the road called aaa to have the suv towed back to bowling green to where I could have it checked the next day when I went to start it it was knocking and smoking and wouldn't take gas. Talked to a local shop and was informed that my motor was blown after he came and looked at it.”Owner report · Engine · Jan 2023
“Rear driver's side door will not close/latch. Latch can be manually moved, but does not engage when shutting door. Currently using bungee cords to keep door closed as I have children and no other vehicle. Vehicle was parked, door was opened from inside to allow passenger to exit, but when they attempted to shut the door, it would not latch closed. No prior problems with the door and no prior warnings/lights. Since door won't close, the door ajar dash light is illuminated and I have to turn my interior lights to off so that they don't remain on while I'm driving”Owner report · Structure · Dec 2022
“The contact owns a 2005 Ford Escape. The contact stated while his son was driving 30 MPH, the vehicle turned off inadvertently. There was no warning light illuminated. The contact's son shifted into neutral(N) and veered to the side of the road. The contact's son was able to restart the vehicle after several attempts. The contact's son then drove to his residence. The dealer and the manufacturer were not notified of the failure. The vehicle was not diagnosed or repaired. The failure mileage was approximately 90,000.”Owner report · Electrical System · Sep 2022
“The contact owns a 2005 Ford Escape. The contact stated that after her father inspected the vehicle, he made her aware that there was damage to the rear subframe. The vehicle was taken to an independent mechanic, where it was diagnosed that the rear subframe needed to be replaced. The contact became aware of NHTSA Campaign Number: 14V165000 (Structure); however, the VIN was not included in the recall. The vehicle was not repaired. The manufacturer was not made aware of the failure. The approximate failure mileage was 100,000. The VIN was not available.”Owner report · Structure · May 2022
When filing, owners marked a crash in 44 of these complaints and injuries in 29 - self-reported to NHTSA, not verified accident statistics.
Recalls - 5 campaigns
Ford Motor Company (Ford) is recalling certain model year 2001-2008 Ford Escape and Mercury Mariner vehicles manufactured March 31, 2001, to September 1, 2009. The affected vehicles are equipped with either a 2.3L or 3.0L engine and have had their CD4E transmission replaced with remanufactured one that was rebuilt between June 11, 2015 through July 15, 2015. These service repair part transmissions have a shift lever bolt that may not be properly tightened. As a result, the shift control lever could disengage from the transmission without warning.
Remedy: Ford will notify owners, and dealers will inspect the transmissions and either tighten the manual shift lever bolt or replace the manual shift lever assembly. These repairs will be performed free of charge. The recall began on October 23, 2015. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 15S28.
Ford Motor Company (Ford) is recalling certain model year 2005-2008 Ford Escape hybrid electric vehicles manufactured October 13, 2003, to June 20, 2008, and 2006-2008 Mercury Mariner hybrid electric vehicles manufactured June 10, 2005, to June 20, 2008. The coolant pump for the hybrid system may fail resulting in the hybrid electronics overheating.
Remedy: Ford will notify owners, and dealers will inspect and replace the original Motor Electronics Coolant (MEC) Pump with an improved brushless pump, free of charge. The recall is expected to begin on October 27, 2014. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 14S19.
The Timken Company (Timken) is recalling certain aftermarket front wheel bearings, part number 510072, sold from January 22, 2015, to May 21, 2015, to be used as service parts on 2001-2012 Ford Escape, 2001-2011 Mazda Tribute, and 2005-2011 Mercury Mariner vehicles. The affected wheel bearings have incorrect dimensions of a 42mm bore, 76mm outer dimension, and 39mm width, instead of a 42mm bore, 78mm outer dimension and a 45mm width.
Remedy: Timken has begun notifying distributors who will offer purchasers replacement wheel bearings, free of charge. The recall began on May 21, 2015. Owners may contact Timken customer service at 1-866-984-6536.
CERTAIN 2004-2005 SPORT UTILITY VEHICLES AND CERTAIN 2001-2003 SPORT UTIITY VEHICLE HAVING REAR LIFTGATE COMPONENTS SERVICED WITH 2004 EQUIVALENT COMPONENTS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 206, 'DOOR LOCKS AND DOOR RETENTION COMPONENTS.' THE REAR LIFTGATE LATCHING SYSTEM DOES NOT MEET THE INERTIA LOAD REQUIREMENT IN ONE DIRECTION.
Remedy: DEALERS WILL REPLACE THE REAR LIFTGATE LATCH RELEASE ROD, THE RELEASE ROD ATTACHMENT CLIP AND THE DOOR HANDLE RETURN SPRING. THE RECALL BEGAN ON MARCH 31, 2005. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673.
CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITHOUT SIDE AIR CURTAINS OR MOONROOFS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 201, "OCCUPANT PROTECTION IN INTERIOR IMPACT." DURING TESTING, THE FREE MOTION HEAD FORM REGISTERED A MEASUREMENT ABOVE THE PERMITTED LIMIT AT THE LEFT HAND A-PILLAR TRIM AREA.
Remedy: DEALERS WILL MAKE MODIFICATIONS TO THE ENERGY ABSORBING MATERIAL LOCATED ABOVE THE HEADLINER IN THE AFFECTED AREA FREE OF CHARGE. THE RECALL BEGAN ON MAY 19, 2006. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
Trouble codes owners mention
OBD-II codes that appear in NHTSA complaints about this car.
Specifications
Factory options offered for the 2005 model year, decoded from the NHTSA vPIC database. Individual vehicles have one of each.
How other years compare
Check your exact Escape by VIN
Recalls and equipment differ between individual vehicles. Decode your VIN to see what applies to yours.
Open VIN decoderFrequently asked questions
Is the 2005 Ford Escape reliable?
NHTSA has 1,584 owner complaints and 5 recall campaigns on record for the 2005 Ford Escape. The most complained-about area is structure (20% of complaints).
At what mileage do 2005 Ford Escape problems usually appear?
Half of the complaints that mention mileage were filed at 106,250 miles or less.
Does the 2005 Ford Escape have open recalls?
5 recall campaigns have been issued, the latest concerning power train:automatic transmission:gear position indication (prndl). Check your specific vehicle by VIN - recall repairs are free at franchised dealers.
Source: NHTSA recall campaigns and owner complaints (public domain). Counts reflect reports on file and are not a defect rate.