Carlexica

2005 Toyota Prius: problems, recalls and reliability

6 recalls and 1,051 owner complaints on record; the weakest area is exterior lighting (31% of complaints); the 2003 and 2004 model years look more trouble-free.

Data updated weekly · latest recall Nov 2012

6
recalls
1,051
owner complaints
4
fire reports
80,000
typical failure mileage, mi

All counts are reports filed with NHTSA in the United States - US market only, not worldwide totals.

Problems tend to appear late (median 80,000 mi)One of the most complained-about Prius years (#5 of 23, age-adjusted)Weak spot: exterior lighting (31%)4 fire reports

Common problems

Computed from 1,051 owner complaints filed with NHTSA for this exact model year.

Exterior Lighting (headlights, taillights)31% · 313 complaints
Electrical System (battery, wiring, electronics)13% · 133 complaints
Service Brakes, Hydraulic (brakes)11% · 108 complaints
Vehicle Speed Control (unintended acceleration, cruise control)8% · 85 complaints
Service Brakes (brakes)7% · 70 complaints
Service Brakes, Electric (brakes)6% · 60 complaints
Eingen faliur acording to dealership Toyota of Anthioc the veicle is on there lot for now but there diagnostic was engine faliureOwner report · Power Train · Feb 2026
ABS actuator failed and had little to no braking action while merging on the freeway. Had to swerve to avoid collision on interstateOwner report · Service Brakes · Jan 2026
The contact owns a 2005 Toyota Prius. The contact stated that while replacing the instrument cluster, the contact discovered that the turn signals were inoperable. The vehicle was taken to the dealer, who determined that an unknown part needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 143,500.Owner report · Exterior Lighting · Oct 2025
Show 7 more owner reports
i had brake warning lights pop up on my dash..my brake actuator fail on my 05 prius.. this is a known issue with toyota prius. the brake actuator is a very important part of the braking system and vehicle is deemed unsafe with a failed actuator/module.. the dealer quoted over 3000 in repairs.. they were covering them for a while and now they are not.. the cost of the repair exceeds the value of vehicle due to the brake actuator being very expensive.. this is something that should have been recalled..Owner report · Service Brakes · Feb 2025
Brake actuator going bad. Safety is put at risk as brakes are slow to work and sometimes don't work at all for a couple of seconds, making sudden stops impossible. Has not been confirmed by dealer. Has not been inspected. ABS and TPMS light would briefly pop up for a couple of seconds on car startup before shutting off.Owner report · Service Brakes · Aug 2024
The contact owns a 2005 Toyota Prius. The contact stated that while driving at an undisclosed speed, the brakes seized. In addition, the contact heard a squealing sound and the ABS warning light illuminated. The contact used the parking brake to stop the vehicle. The vehicle was not diagnosed or repaired by an independent mechanic or the dealer. The manufacturer was not made aware of the failure. The contact stated that the odometer was inoperable and failed to display the correct mileage. The contact stated that the odometer was stuck on 299,999.Owner report · Electrical System · Jun 2024
This has been an on going issue with all of toyota hybrids, the abs actuator which control the brakes isn't safe to drive around when not functioning right. Dealership will not replace im suprise that this has no been a recall as its a safety hazard on the road not only for the driver but putting others in danger. My brakes sometimes is floored to the ground with minimal stoppage.Owner report · Service Brakes · May 2024
Prius have a LONG known problem w/ braking systems (over 15 years) defaulting to SOFT brake pedal that (will) kill any driver. Toyota decided to avoid a recall by paying off a few repair jobs, during warranty. They have created a new part to resolve the issue. $4000 to replace a brake pump. Most fail at 150k miles. . [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)Owner report · Service Brakes · Mar 2024
I had lost functionality for some buttons on the steering wheel that didn't directly impact safety. On replacing the clockspring mechanism inside the whweel I decided to inspect the old unit. Four of the lines in the flex cable are impacted by corrosion, three have already failed. The fourth line is one of the airbag's electrical lines. I'm filing an issue report because the airbag would be next impacted by this failure and I believe there's a fair chance the corroded line could fail during the vehicle's attempt to fire the airbag on the wheel.Owner report · Air Bags · Oct 2023
11 months ago I had a brand new Toyota ABS brake actuator installed on my 2005 Prius. Less than a year later, it is failing again. Since I've driven the car more than 12,000 miles Toyota will not replace the part under warranty. Toyota charges $1800 for the part alone. I had an abs brake actuator fail on a previous 2007 Prius as well. Toyota forums imply this is a too common problem.Owner report · Service Brakes · Sep 2023

When filing, owners marked a crash in 102 of these complaints and injuries in 66 - self-reported to NHTSA, not verified accident statistics.

Recalls - 6 campaigns

VEHICLE SPEED CONTROL:ACCELERATOR PEDAL09V388000 · Oct 2009

TOYOTA IS RECALLING CERTAIN MODEL YEAR 2004-2010 PASSENGER VEHICLES. THE ACCELERATOR PEDAL CAN GET STUCK IN THE WIDE OPEN POSITION DUE TO ITS BEING TRAPPED BY AN UNSECURED OR INCOMPATIBLE DRIVER'S FLOOR MAT.

Remedy: TOYOTA FILED AN AMENDED DEFECT REPORT ON NOVEMBER 25, 2009, STATING THAT DEALERS WILL MODIFY THE ACCELERATOR PEDAL AND, ON CERTAIN VEHICLES, ALTER THE SHAPE OF THE FLOOR SURFACE UNDER THE PEDAL. THESE CHANGES ADDRESS THE RISK OF PEDAL ENTRAPMENT DUE TO INTERFERENCE WITH THE FLOOR MAT. REDESIGNED ACCELERATOR PEDALS WILL BECOME AVAILABLE BEGINNING IN APRIL 2010 AND DEALERS WILL REPLACE ANY MODIFIED PEDAL WITH THE NEW PEDAL IF DESIRED. ALSO, DEALERS WILL REPLACE ANY GENUINE TOYOTA OR LEXUS ALL-WEATHER FLOOR MATS WITH REDESIGNED ALL-WEATHER MATS, OR REPURCHASE THE PREVIOUS MATS FROM OWNERS WHO DO NOT WANT THE NEW ONES. ADDITIONALLY, SOFTWARE MODIFICATIONS WILL BE INSTALLED ON CAMRY, AVALON AND LEXUS ES 350, IS 350 AND IS 250 MODELS THAT WILL ENSURE THAT THE BRAKE OVERRIDES THE ACCELERATOR IN THE EVENT BOTH BRAKE AND ACCELERATOR PEDALS ARE APPLIED. TOYOTA WILL BEGIN MAILING LETTERS TO OWNERS ON DECEMBER 31, 2009. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331, LEXUS AT 1-800-255-3987.

HYBRID PROPULSION SYSTEM: INVERTER12V536000 · Nov 2012

Toyota is recalling certain model year 2004-2009 Prius vehicles manufactured August 6, 2003, through March 30, 2009 and FCHV-adv vehicles manufactured December 12, 2008, through September 13, 2011. During manufacturing, a scratch may have occurred inside of the electrically driven water pump at the coil wire. The coil wire may corrode at the scratched portion.

Remedy: Toyota will notify its owners, and dealers will replace the electric water pump, free of charge. The recall began on January 17, 2013. Owners may contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331.

STEERING:GEAR BOX:SHAFT SECTOR12V537000 · Nov 2012

Toyota is recalling certain model year 2004-2009 Prius vehicles manufactured August 5, 2003, through March 30, 2009. The affected vehicles have a steering intermediate extension shaft assembly built with metal splines that complete the connection from the steering wheel to the steering gear. These splines may have been manufactured with an insufficient hardness.

Remedy: Toyota will notify owners, and dealers will inspect the extension shaft and replace it if it is one with insufficient hardness, free of charge. The recall began during December 2012. Owners may contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331.

STEERING:ELECTRIC POWER ASSIST SYSTEM06V188000 · May 2006

THE INTERMEDIATE SHAFT AND SLIDING YOKE IN THE ELECTRIC POWER STEERING SYSTEM CAN CRACK WHEN LARGE FORCES ARE APPLIED AND THE CONNECTION MAY SEPARATE OR THE SLEEVE MAY FRACTURE.

Remedy: TOYOTA WILL REPLACE THE STEERING INTERMEDIATE SHAFT AND INSPECT THE SLIDING YOKE AND REPLACE IT IF NECESSARY. THE RECALL BEGAN ON JUNE 9, 2006. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.

EQUIPMENT:OTHER:LABELS10V036000 · Feb 2010

SOUTHEAST TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2011 PASSENGER VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.

Remedy: DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT SOUTHEAST TOYOTA AT 1-800-301-6859.

AIR BAGS06V096000 · Apr 2006

ON CERTAIN VEHICLES, DUE TO IMPROPER ASSEMBLY OF THE AIR BAG INFLATOR, WHICH IS USED IN THE SIDE AIR BAG, THE CURTAIN SHIELD AIR BAG, AND THE KNEE AIR BAG ASSEMBLY, SOME INFLATORS WERE PRODUCED WITH AN INSUFFICIENT AMOUNT OF THE HEATING AGENTS NECESSARY FOR PROPER AIR BAG DEPLOYMENT. IN THIS CONDITION, THE EXPANSION FORCE OF THE GAS MAY BE INSUFFICIENT TO PROPERLY INFLATE THE AIR BAG WHEN THE SRS SYSTEM IS ACTIVATED DURING A CRASH.

Remedy: DEALERS WILL REPLACE THE SPECIFIC SRS AIR BAG. THE RECALL BEGAN ON APRIL 6, 2006. OWNERS MAY CONTACT TOYOTA AT 1-888-270-9371, SCION AT 1-866-548-1851, OR LEXUS AT 1-800-255-3987.

How other years compare

Check your exact Prius by VIN

Recalls and equipment differ between individual vehicles. Decode your VIN to see what applies to yours.

Open VIN decoder

Frequently asked questions

Is the 2005 Toyota Prius reliable?

NHTSA has 1,051 owner complaints and 6 recall campaigns on record for the 2005 Toyota Prius. The most complained-about area is exterior lighting (31% of complaints).

At what mileage do 2005 Toyota Prius problems usually appear?

Half of the complaints that mention mileage were filed at 80,000 miles or less.

Does the 2005 Toyota Prius have open recalls?

6 recall campaigns have been issued, the latest concerning vehicle speed control:accelerator pedal. Check your specific vehicle by VIN - recall repairs are free at franchised dealers.

Source: NHTSA recall campaigns and owner complaints (public domain). Counts reflect reports on file and are not a defect rate.