2018 Mercedes-Benz Sprinter 3500: problems, recalls and reliability
10 recalls and 9 owner complaints on record; most reports concern vehicle speed control.
Data updated weekly · latest recall Feb 2021
All counts are reports filed with NHTSA in the United States - US market only, not worldwide totals.
Common problems
Computed from 9 owner complaints filed with NHTSA for this exact model year.
“The contact owns a 2018 Mercedes Benz Sprinter 3500. The contact stated that while starting the vehicle, the contact noticed that the Diesel Exhaust Fluid (DEF) warning light was illuminated. The vehicle was taken to the dealer where it was diagnosed and determined that the Diesel Exhaust Fluid (DEF) tank had failed and needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure and referred the contact to the NHSTA Hotline for assistance. The approximate failure mileage was 15,000.”Owner report · Fuel System, Diesel · Feb 2025
“The contact owns a 2018 Mercedes-Benz Sprinter 3500. The contact stated that while operating the vehicle, the ABS, check engine, and cruise control warning lights illuminated. The cause of the failure was not yet determined. The contact indicated that the vehicle was recently serviced under NHTSA Campaign Number: 21V042000 (Electronic Stability Control) however, the failure occurred. The local dealer and manufacturer were notified of the failure. The approximate failure mileage was 18,000.”Owner report · Electronic Stability Control · Nov 2021
“The contact owns a 2018 Mercedes-Benz Sprinter 3500. The contact received a recall notification for NHTSA Campaign Numbers: 20V663000 (Steering) and 21V042000 (Electronic Stability Control) however, the dealer informed the contact that the part for the recall repair was not yet available. The contact contacted Mercedes-Benz of Westminster (10391 Westminster Blvd, Westminster, CO 80020) confirmed the first dealer's information. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was notified of the issue. The contact had not experienced a failure. Parts distribution disconnect.”Owner report · Steering · Sep 2021
Show 1 more owner reports
“When turning a corner,engine raced to 45 mph without my foot on the throttle.almost lost control.had to put vehicle,meredes sprinter 3500,into neutral to stop it.had previously had the dealer repair speed sensors three other times.warning lights come on and I loose cruise control.dangerous condition.mb should re engineer the part and install in affected vehicles.dealer continues to install defective parts.”Owner report · Vehicle Speed Control · Jan 2021
Recalls - 10 campaigns
Daimler Vans USA, LLC (DVUSA) is recalling certain 2018-2019 Mercedes-Benz and Freightliner Sprinter vehicles. The screw connection on the upper hood catch may have been improperly tightened. As a result, factors such as the vehicle's speed, wind resistance and road conditions may cause the hood to open while the vehicle is being driven.
Remedy: DVUSA will notify owners, and dealers will inspect the screw connection, tightening it as necessary, free of charge. The recall began November 1, 2019. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VS3HAUBOSS.
Daimler Vans USA, LLC (DVUSA) is recalling certain 2015-2020 Mercedes Benz Sprinter and Freightliner Sprinter vehicles. The hydraulic power steering return line hoses may detach at their connection points under certain operating conditions, causing hydraulic fluid to leak.
Remedy: DVUSA will notify owners, and dealers will check the return line connections of the power steering system, correcting it as needed, free of charge. The recall began December 23, 2020. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this campaign is NV3LETULPE.
Daimler Vans USA, LLC (DVUSA) is recalling certain 2018-2019 Sprinter and Metris vehicles. The vehicles left the reassembly plant without the final quality inspection of safety-relevant parts or bolt connections, resulting in possible unknown safety risks.
Remedy: DVUSA will notify owners, and vehicles will be returned to the reassembly plant for comprehensive inspection and, if necessary, corrective action, free of charge. The recall began November 15, 2019. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VSX566ZP25.
Daimler Vans USA, LLC (DVUSA) is recalling certain 2018-2019 Mercedes-Benz and Freightliner Sprinter vehicles. The airbag systems may not have been activated after vehicle production. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 208, "Occupant Crash Protection."
Remedy: DVUSA will notify owners, and dealers will inspect the vehicles to determine if the airbag systems have been activated, correcting them as necessary, free of charge. DVUSA issued owners an interim notification on November 22, 2019. The recall began February 10, 2020. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VS3AIRIGEL.
Daimler Vans USA, LLC (DVUSA) is recalling certain 2018 Freightliner Sprinter 2500 and 3500 and Mercedes-Benz Sprinter 2500 and 3500 vehicles. The right side door latches may have been built with incorrect components. As a result, when the doors are electronically unlocked, the right-side doors may not be able to be opened from inside or outside of the vehicle.
Remedy: DVUSA will notify owners, and dealers will inspect and replace the locks if necessary, free of charge. The recall began January 31, 2019. Owners may contact DVUSA at 1-877-762-8267.
Daimler Vans USA, LLC (DVUSA) is recalling certain 2018-2019 Mercedes-Benz Sprinter and Freightliner Sprinter vehicles. The spare tire label may indicate the maximum speed at 55 kilometers per hour (kph) rather than as 34 miles per hour (mph).
Remedy: DVUSA will notify owners, and Mercedes-Benz or Freightliner Sprinter dealers will replace it with the label with the correct maximum speed information indicated in miles per hour, free of charge. The recall began May 15, 2020. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VS3BEGRESS.
Daimler Vans USA, LLC (DVUSA) is recalling certain 2018-2019 Mercedes-Benz Sprinter and Freightliner Sprinter vehicles. The spare tire label indicating the maximum speed may have not been affixed to the spare tire.
Remedy: DVUSA will notify owners, and Mercedes-Benz or Freightliner Sprinter dealers will attach the speed limitation label on the spare wheel, free of charge. The recall began May 15, 2020. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VS3BEGREPP.
Daimler Vans USA, LLC (DVUSA) is recalling certain 2018-2019 Mercedes-Benz Sprinter and Metris vehicles. The affected vehicles left the reassembly plant without the final quality inspection of safety-relevant parts or bolt connections, resulting in possible unknown safety risks.
Remedy: DVUSA will notify owners, and dealers will complete the final quality inspection, free of charge. The recall began May 17, 2019. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VSX566ZP25.
Daimler Vans USA, LLC (DVUSA) is recalling certain 2018-2019 Mercedes-Benz and Freightliner Sprinter 1500, 2500, 3500 and 4500 vehicles. The rear side windows may be single-pane safety glass instead of laminated safety glass.
Remedy: DVUSA will notify owners, and Mercedes-Benz or Freightliner dealers will replace the single-pane safety glass with laminated safety glass., free of charge. DVUSA issued owners an interim notification on August 16, 2019. The recall began January 21, 2020. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VS3VERGLAS.
Daimler Vans USA, LLC (DVUSA) is recalling certain 2012-2018 Mercedes Benz Sprinter 3500 and Freightliner Sprinter 3500 vehicles upfitted into campers or recreational vehicles. The Electronic Stability Control (ESC) unit may become disabled on these vehicles.
Remedy: DVUSA will notify owners, and dealers will replace the rear-wheel speed sensor with a more robust sensor, free of charge. DVUSA issued owners an interim notification on March 10, 2021. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is NC3DREZAHA.
How other years compare
Check your exact Sprinter 3500 by VIN
Recalls and equipment differ between individual vehicles. Decode your VIN to see what applies to yours.
Open VIN decoderFrequently asked questions
Is the 2018 Mercedes-Benz Sprinter 3500 reliable?
NHTSA has 9 owner complaints and 10 recall campaigns on record for the 2018 Mercedes-Benz Sprinter 3500. The most complained-about area is vehicle speed control.
Does the 2018 Mercedes-Benz Sprinter 3500 have open recalls?
10 recall campaigns have been issued, the latest concerning latches/locks/linkages:hood:latch. Check your specific vehicle by VIN - recall repairs are free at franchised dealers.
Source: NHTSA recall campaigns and owner complaints (public domain). Counts reflect reports on file and are not a defect rate.