2016 Mercedes-Benz Sprinter 3500: problems, recalls and reliability
16 recalls and 61 owner complaints on record; the weakest area is air bags (20% of complaints); the 2015 and 2017 and 2018 model years look more trouble-free.
Data updated weekly · latest recall Feb 2021
All counts are reports filed with NHTSA in the United States - US market only, not worldwide totals.
Common problems
Computed from 61 owner complaints filed with NHTSA for this exact model year.
“Power steering return hose slipped off 1/2" and fluid leak. Has a recall, but not applicable to this vin. Although it appears to be effecting it? Secured line to best abilities.”Owner report · Steering · Nov 2024
“trucks cut speed limit 65 to 10 normal highway i do understood %35 degrees slow down but its only %2 degrees uprise there is no power at engine rpm is shows less then 1 rpm and even if press the gas pedal all the way the truck does not accelerate like truck is lock right there very dangers any one drive back of me they are not accept that much speed change they are in dangers scarr to drive truck be couse same one get git back of truck and can get kill”Owner report · Fuel/Propulsion System · Oct 2021
“The NHTSA law requires that the recall be done on a timely manner . Mercedes benz is not doing this . The wheel sensor recall is being not being done in a timely manner by Mercedes benz. They are typically making appointments 1 month to 3 months out to do a recall that takes 40 minutes to accomplish. .They are purposely endangering sprinter RV owners by their untimely repair schedule.”Owner report · Electrical System · Aug 2021
Show 7 more owner reports
“Tl* the contact owns a 2016 mercedes-benz sprinter 3500. The contact discovered that the vehicle was included in NHTSA campaign number: 21v042000 (electronic stability control) however, the parts to do the recall repair was unavailable. Mercedes-benz of wilsonville (25035 sw parkway ave, wilsonville, or 97070, 503-454-5000) was contacted and it was confirmed that the part was not yet available. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.”Owner report · Electronic Stability Control (Esc) · Mar 2021
“Wheel speed sensors keep failing. I have had eight sensors fail in three years of ownership. Transmission shifts erratically, speed surges, ABS, check engine light and braking is impaired. This happens when vehicle is in motion.”Owner report · Electrical System · Jan 2021
“Rear wheel speed sensor had to be replaced at 30,000 miles and now both front wheel sensors are faulty at 50.000 miles. In my reading this is a commonly faulty part and it cost $ 760.00 to replace both sensors. Fortunately the first sensor was under warranty. It would be greatly appreciated if you will look into this issue. Because you cannot afford to trade an rv. I was on a trip when the indicator lights came on on dash and I was able to drive 7 hours homes. My owners manual expressed I should seek technical assistance asap.”Owner report · Service Brakes · Nov 2020
“Both left and right rear wheel speed sensors failed resulting in transmission limited to 2nd gear and back up. Vehicle has driven 9800 miles total.”Owner report · Wheels · Nov 2020
“Third-time speed sensor failed while driving ' all 3 times while driving on highway. Causes the vehicle to speed up / slow down and lurch with the engine doing high revs. Cruise control become inoperable. ABS, forward collision, and parking sensors become inoperable. Brakes perform erratically for several moments and then ABS indicates it is inoperable. Van becomes hazardous to drive while the electronics attempt to sort out what is going on. Very glad I was not in congested traffic each time this happens as the van becomes unstable. M-benz solution is to replace sensor ' this does not seem safe nor viable long term fix.”Owner report · Forward Collision Avoidance · Nov 2020
“Driving along in cruise control around 65 mph all of a sudden cruise control stops working and vehicle bucks quite a bit,very startling.then I notice on dashboard the so called three stooges lights appear.this was my first encounter around 18,000 mi.august 2020.problem fixed in ct under warranty. Two months later driving through virginia,same stooge lights appear in the mountains shifting erratically.called m b tech, very helpful,directed me to mercedes benz of fredericksburg va 77 miles away.inconvenienced but grateful work was done under warranty.I believe this is a hazard on the roads and should be a recall.”Owner report · Service Brakes · Oct 2020
“Wheel speed sensor failed at 10000 miles (refer to previous complaint), again fails at 20000 miles causing erratic transmission shifting and propulsion without driver input.”Owner report · Vehicle Speed Control · Oct 2020
When filing, owners marked a crash in 3 of these complaints and injuries in 6 - self-reported to NHTSA, not verified accident statistics.
Recalls - 16 campaigns
Daimler Vans USA, LLC (DVUSA) is recalling certain 2016 Mercedes-Benz Sprinter 2500/3500 vehicles. The affected vehicles were manufactured without a driveshaft catch strap, allowing a loose driveshaft to strike the fuel tank.
Remedy: DVUSA will notify owners, and dealers will install the missing catch strap for the driveshaft, free of charge. Daimler issued an interim notification to owners on November 17, 2017. The recall began on December 21, 2017. Owners may contact DVUSA customer service at 1-877-762-8267.
Daimler Vans USA, LLC (DVUSA) is recalling certain model year 2016 Mercedes-Benz and Freightliner Sprinter 2500 and 3500 vehicles manufactured March 1, 2016, to May 31, 2016. The bolts connecting the lower seat belt connection to the rear bench seat may not have been properly tightened.
Remedy: DVUSA will notify owners, and Sprinter dealers will inspect the connecting bolts, tightening them as necessary, free of charge. The recall began on November 18, 2016. Owners may contact DVUSA customer service at 1-877-762-8267.
Daimler Vans USA, LLC (DVUSA) is recalling certain 2015-2020 Mercedes Benz Sprinter and Freightliner Sprinter vehicles. The hydraulic power steering return line hoses may detach at their connection points under certain operating conditions, causing hydraulic fluid to leak.
Remedy: DVUSA will notify owners, and dealers will check the return line connections of the power steering system, correcting it as needed, free of charge. The recall began December 23, 2020. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this campaign is NV3LETULPE.
Daimler Vans USA, LLC (DVUSA) is recalling certain 2016 Mercedes-Benz Sprinter 2500 and 3500 vehicles. The label on the B-pillar may state a higher maximum vehicle load capacity than the vehicle is designed for. As such, these vehicles fail to comply with the requirements of 49 CFR Part 567, "Certification."
Remedy: DVUSA will notify owners, and dealers will check the label and replace it if necessary, free of charge. The recall began on December 15, 2017. Owners may contact DVUSA customer service at 1-877-762-8267.
Midwest Automotive Designs, LLC (Midwest) is recalling certain model year 2016 Mercedes Benz Sprinter 2500 and 3500 vehicles manufactured July 1, 2016, to September 30, 2016, equipped with certain left side seat adjusters, model number 486077 manufactured by Atwood. The affected seat adjusters may allow the seats to move in the event of a crash. As such, these adjusters fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 210, "Seat Belt Assembly Anchorages", and 207 "Seating Systems."
Remedy: Midwest will notify owners, and dealers will replace the left slide track, free of charge. The recall began on December 22, 2016. Owners may contact Midwest customer service at 1-574-522-4878.
Daimler Vans USA, LLC (DVUSA) is recalling certain model year 2015-2016 Mercedes-Benz Sprinter 2500 and 3500 vehicles manufactured May 31, 2015, to April 30, 2016, and 2015-2016 Freightliner Sprinter 2500 and 3500 vehicles manufactured May 1, 2015, to April 30, 2016. The affected vehicles are configured to have super-high roofs, but may not be equipped with the required crash pads.
Remedy: DVUSA will notify owners, and dealers will install the required crash-pads, free of charge. The recall began on August 11, 2016. Owners may contact DVUSA customer service at 1-877-762-8267.
Daimler Vans USA, LLC (DVUSA) is recalling certain 2016 Mercedes-Benz Sprinter 2500 and 3500 vehicles and Freightliner Sprinter 2500 and 3500 vehicles. The bracket for the center support bearing of the drive shaft may not have been properly welded.
Remedy: DVUSA will notify owners and dealers will install three additional rivets to secure the bracket, free of charge. Interim notices informing owners of the safety risk were mailed on May 5, 2017. The recall began on July 7, 2017. Owners may contact DVUSA customer service at 1-877-762-8267.
Daimler Vans USA, LLC (DVUSA) is recalling certain 2016 Mercedes-Benz and Freightliner Sprinter 2500 and 3500 vehicles equipped with reinforced front axles. The affected vehicles have tire labels on the B-pillar that list a tire pressure that is too low.
Remedy: DVUSA will notify owners, Freightliner Sprinter and Mercedes-Benz dealers will check and replace the tire label, as necessary, free of charge. The recall began on August 5, 2017. Owners may contact DVUSA customer service at 1-877-762-8267.
Daimler Vans USA, LLC (DVUSA) is recalling certain 2014-2017 Freightliner Sprinter 2500 and 3500 and Mercedes-Benz Sprinter 2500 and 3500 vehicles. These vehicles are equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules used as original equipment or replacement equipment. In the event of a crash necessitating deployment of the passenger frontal air bag, these inflators may explode due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling.
Remedy: DVUSA will notify owners, and dealers will replace the front passenger air bag module, free of charge. The recall began March 15, 2019. Owners may contact DVUSA customer service at 1-877-762-8267.
Daimler Vans USA, LLC (DVUSA) is recalling certain 2015-2017 Freightliner Sprinter 2500 and 3500 and Mercedes-Benz Sprinter 2500 and 3500 vehicles. These vehicles are equipped with certain air bag inflators assembled as part of the driver frontal air bag modules used as original equipment or replacement equipment. In the event of a crash necessitating deployment of the driver frontal air bag, these inflators may explode due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling.
Remedy: DVUSA will notify owners, and dealers will replace the front driver air bag module, free of charge. The recall is began March 15, 2019. Owners may contact DVUSA customer service at 1-877-762-8267.
Daimler Vans USA, LLC (DVUSA) is recalling certain 2012-2018 Mercedes Benz Sprinter 3500 and Freightliner Sprinter 3500 vehicles upfitted into campers or recreational vehicles. The Electronic Stability Control (ESC) unit may become disabled on these vehicles.
Remedy: DVUSA will notify owners, and dealers will replace the rear-wheel speed sensor with a more robust sensor, free of charge. DVUSA issued owners an interim notification on March 10, 2021. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is NC3DREZAHA.
Daimler Vans USA, LLC (DVUSA) is recalling certain 2016-2017 Mercedes-Benz Sprinter 2500 and Sprinter 3500 vehicles, equipped with folding seats (sales code S20). The unloaded vehicle weight (UVW) label on these incomplete vehicles may be incorrect.
Remedy: DVUSA will notify owners, and dealers will replace the UVW label and inspect the vehicle to make sure that it is not overloaded, free of charge. The recall began on April 3, 2018. Owners may contact DVUSA customer service at 1-877-762-8267.
Daimler Vans USA, LLC (DVUSA) is recalling certain 2013-2016 Mercedes-Benz Sprinter 2500 and 3500 and Freightliner Sprinter 2500 and 3500 vans. These vehicles were manufactured without a reinforcement plate and protective bracket on the air bag control unit. As a result, the air bag control unit may not remain functional after the initial impact, possibly preventing additional air bags from deploying in response to a secondary impact.
Remedy: DVUSA will notify owners, and dealers will install a reinforcement plate and protective bracket around the air bag control unit, free of charge. The recall began on May 26, 2017. Owners may contact DVUSA customer service at 1-877-762-8267.
Daimler Vans USA, LLC (DVUSA) is recalling certain model year 2015-2016 Mercedes-Benz and Freightliner Sprinter 2500 and 3500 vans manufactured April 29, 2015, to December 15, 2015. The affected vehicles have a tire pressure label that incorrectly states a higher maximum load capacity than the vehicle is designed for.
Remedy: DVUSA will notify owners, and Mercedes-Benz and Freightliner dealers will replace the incorrect tire pressure label, free of charge. The recall began March 2016. Owners may contact DVUSA customer service at 1-877-762-8267.
Midwest Automotive Designs, LLC (Midwest) is recalling certain Custom Vans and Camper Van recreational vehicles built on 2014-2017 Mercedes Benz Sprinter chassis and 2016-2017 RAM Promaster chassis. These vehicles are equipped with Kidde Plastic-Handle or Push Button 'Pindicator' fire extinguishers that may become clogged, preventing the extinguisher from discharging as expected or excessive force may be needed to activate the extinguisher. Additionally, in certain models, the nozzle may detach from the valve assembly with enough force that it could cause injury and also render the product inoperable. For a full list of the affected fire extinguisher models visit: https://static.nhtsa.gov/odi/rcl/2017/RMISC-17E062-5427.pdf
Remedy: Midwest will notify owners, and dealers will replace the fire extinguisher with a different brand, free of charge. The recall began on December 11, 2017. Owners may contact Kidde customer service for their replacement extinguisher at 1-855-262-3540, or online at www.kidde.com and click on "Product Safety Recall" for more information.
Daimler Vans USA, LLC (DVUSA) is recalling certain model year 2015-2016 Mercedes Benz and Freightliner Sprinter 2500 and 3500 vehicles manufactured April 1, 2015, to October 31, 2015. The affected vehicles may have had multiple layers of paint applied, and as a result, in a crash, the windows may separate from the vehicle when the outer layer of paint peels from the layer below.
Remedy: DVUSA will notify owners, and dealers will remove the windows and inspect the paintwork, repainting the vehicles as necessary, free of charge. This recall began August 4, 2016. Owners may contact DVUSA customer service at 1-770-705-2070.
How other years compare
Check your exact Sprinter 3500 by VIN
Recalls and equipment differ between individual vehicles. Decode your VIN to see what applies to yours.
Open VIN decoderFrequently asked questions
Is the 2016 Mercedes-Benz Sprinter 3500 reliable?
NHTSA has 61 owner complaints and 16 recall campaigns on record for the 2016 Mercedes-Benz Sprinter 3500. The most complained-about area is air bags (20% of complaints).
At what mileage do 2016 Mercedes-Benz Sprinter 3500 problems usually appear?
Half of the complaints that mention mileage were filed at 17,650 miles or less.
Does the 2016 Mercedes-Benz Sprinter 3500 have open recalls?
16 recall campaigns have been issued, the latest concerning power train:driveline:driveshaft. Check your specific vehicle by VIN - recall repairs are free at franchised dealers.
Source: NHTSA recall campaigns and owner complaints (public domain). Counts reflect reports on file and are not a defect rate.