2009 Toyota Highlander: problems, recalls and reliability
10 recalls and 174 owner complaints on record; the weakest area is service brakes (20% of complaints).
Data updated weekly · latest recall Jun 2016
All counts are reports filed with NHTSA in the United States - US market only, not worldwide totals.
Common problems
Computed from 174 owner complaints filed with NHTSA for this exact model year.
“The contact owns a 2009 Toyota Highlander. The contact stated that while driving at an undisclosed speed, the vehicle made an abnormal, loud clunking sound. The ABS, the parking brake, and the traction control warning lights were illuminated. The vehicle was taken to an independent mechanic, where it was diagnosed that the brake actuator assembly had failed and needed to be replaced. The vehicle was not repaired. The dealer was not contacted. The manufacturer was made aware of the failure. The failure mileage was approximately 137,000.”Owner report · Service Brakes, Hydraulic · Jul 2025
“the ABS pump and actuator on this vehicle have failed. The warning lights on dash indicate ABS, BRAKE, TRACTION CONTROL, and (!). Toyota knows that the actuator on over one hundred thousand vehicles has an internal leakage (which can not be seen on visual inspection). I have requested Toyota to repair and replace this manufacturing malady and Toyota has declined any assistance.”Owner report · Service Brakes · Mar 2024
“Brakes failed at a low rate of speed despite pumping them and pushing the petal all the way to the floor. Several witnesses in the car support this narrative. Vehicle ended up slowly rolling into the car in front of us. Minimal damage to both. Took it in to the dealership and they said the brakes appear fine.”Owner report · Service Brakes · Feb 2024
Show 7 more owner reports
“My airbag light came on and I don't understand why the airbag light came on. I took it to a auto shop and they said I would have to take it to a Toyato dealer. Also, my emergency brake is all the way to the floor and it has never released. It will not release at all. It has been that way ever since I bought the vehicle.”Owner report · Forward Collision Avoidance · Dec 2022
“Similar to what many other complainants have stated, the ABS has apparently failed. There are clunking noises and warning messages to pull over and not drive the vehicle. This is a known issue on these vehicles and Toyota did a very short recall that expired in 2020. The recall required that your vehicle was experiencing the problem at that moment, so everyone who has this issue after 2020 gets a $3k repair bill or an unsafe vehicle.”Owner report · Service Brakes · Dec 2022
“2008-2010 Toyota Highlander vehicles are at risk for a brake malfunction caused by the ABS system. Toyota issued a TSB in May 2019 but that was only covered IF you had the issue during that specific time period of the issued TSB. The ABS issue seems to be malfunction around 135000-150000 miles and cause a brake failure or lockup. Since the TSB was issued, it voids 3rd party warranty coverage and Toyota will not assist with cost at almost $3000 even though they are aware of the issue.”Owner report · Service Brakes · May 2022
“While driving I heard a clunking noise and warning lights for ABS, slip indicator, brake warning system instructing me to pull over and service vehicle as it was unsafe to drive I took the vehicle to local dealership and they found that the ABS Actuator and Brake pump had failed and needed to be replaced. While researching the issue I found that the manufacturer had issued an extended warranty service bulletin but did not issue a recall. I have included the service bulletin below.”Owner report · Service Brakes · Apr 2022
“Braking system warning lights came on. Prior to that the vehicle was making several clunking noises from the front and rear mostly when braking. The stopping distance while braking has been reduced to nearly double the distance while much more force is needed to be applied to the brake pedal to get the vehicle to come to a stop.”Owner report · Service Brakes · Mar 2022
“on 26/Jan/2022 i driving on highway suddendly the front wheel passanger side lock, luckily i quickly get off drive land to emergency land. The Brake Malfuntion light come up, i so scare, do not what happen. But i should do complaint about brake system on this vehicle. Thanks. Vu Dam.”Owner report · Suspension · Jan 2022
“Engine oil filler cap had interior motor part , melt through while driving , almost hurling all the way through , 2 inch cylindrical part viewed when opening hood to inspect damage . Braking , trac and vsc engaged and motor failed almost dieing , abs allowed brake pedal to go to floor with vehicle just stopping enough to move from traffic . No injuries and No collisions happened due to violent engine combusting or braking disabled , incident happened at 10 mph entering a parking lot .”Owner report · Engine · Jul 2021
When filing, owners marked a crash in 8 of these complaints and injuries in 10 - self-reported to NHTSA, not verified accident statistics.
Recalls - 10 campaigns
Toyota is recalling certain model year 2006-2010 Highlander hybrid vehicles manufactured February 16, 2005, through July 29, 2010; and model year 2006-2008 Lexus RX400h vehicles manufactured February 23, 2005, through December 2, 2008. The Intelligent Power Module (IPM) inside the inverter module may contain transistors that have higher operating temperatures than the solder can support and the transistors may be heat damaged by the solder. If this occurs, various warning lamps, including the malfunction indicator lamp, slip indicator light, brake system warning light, and master warning light, will be illuminated on the instrument panel.
Remedy: Toyota will notify owners, and dealers will replace the IPM free of charge. Owners may contact Toyota at 1-800-331-4331. Vehicles that had their IPM replaced under recall 11V-342 are not affected by this campaign.
Toyota Motor Company (Toyota) is recalling certain model year 2009-2011 Tundra, Sequoia, Corolla, Corolla Matrix and Scion xB, 2008-2011 Highlander and Highlander Hybrid, 2007 Camry and Camry Hybrid, 2009 Camry and Camry Hybrid, 2006-2011 RAV4, 2006-2010 Yaris, and 2009-2010 Scion xD and Pontiac Vibe vehicles. During the manufacturing of the Power Window Master Switch (PWMS), grease lubricant may have been inconsistently applied to the sliding electrical contacts.
Remedy: Toyota will notify owners, and dealers will inspect the switch, applying a lubricant if no abnormality is found. If abnormality is found, the PWMS circuit board will be replaced, free of charge. The recall is expected to begin December 20, 2015. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's number for this recall is C0M.
Southeast Toyota Distributors, LLC (SET) is recalling certain model year 2010-2011 Prius and Corolla, 2009-2011 Venza, 2006-2010 Avalon, 2007-2010 FJ Cruiser, 2005-2011 Sienna and Sequoia, 2006-2011 Tacoma 4x2 and 4x4, Camry, Highlander, Tundra 4x2 and 4x4, and 2007-2011 Rav4 and 4Runner. The affected vehicles may experience compression of the seat cushion which may damage the seat heater wiring.
Remedy: SET will notify owners, and dealers will disconnect the heaters with copper strand heating elements and refund the purchase price of the seat heater accessory, free of charge. The recall is expected to began in January 2015. Owners may contact SET customer service at 1-866-405-4226.
Southeast Toyota Distributors, LLC (SET) is recalling certain 2005-2011 4Runner, Highlander, Sequoia, and Sienna, 2005-2010 Avalon and Tundra, 2006-2008 Camry Solara, 2006-2010 Highlander hybrid, 2006-2011 Rav4 and Tacoma, 2007-2010 FJ Cruiser, 2007-2011 Camry hybrid, 2009-2010 Venza, 2010-2012 Prius, 1988-1990 and 2005-2010 Camry, and 1989 and 2009-2010 Corolla vehicles equipped with aftermarket accessory seat heaters with a copper strand heating element. The electrical wiring in the seat heaters may be damaged when the seat cushion is compressed.
Remedy: SET will notify owners, and dealers will disconnect the seat heaters, free of charge, and refund the purchase price of the seat heater accessory. The recall began on July 14, 2016. Owners may contact SET customer service at 1-866-405-4226. SET number for this recall is SET16B.
TOYOTA IS RECALLING 27,080 MODEL YEAR 2005 THROUGH 2010 PASSENGER CARS BUILT FROM SEPTEMBER 1, 2005 TO MAY 4, 2009. THESE VEHICLES WERE NOT EQUIPPED WITH LOAD CARRYING CAPACITY MODIFICATION LABELS WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS."
Remedy: TOYOTA WILL NOTIFY OWNERS AND PROVIDE THEM WITH A NEW, ACCURATE LABEL TO BE INSTALLED OVER THE INACCURATE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON AUGUST 18, 2009. OWNERS MAY CONTACT TOYOTA AT 1-888-270-9371.
Southeast Toyota Distributors, LLC (SET) is recalling certain models interspersed through model years 2009 through 2013 as follows: model year 2009-2012 Tacoma, 4Runner, Camry, Camry Hybrid, Prius, and RAV4; model year 2009-2010 Avalon, FJ Cruiser, and Highlander Hybrid; model year 2010-2013 model year Corolla, Sienna and Tundra; model year 2009-2013 Highlander and Venza; model year 2012 Prius V; and model year 2010-2012 Sequoia. During modification by SET to include accessories such as leather seat covers, seat heaters or headrest DVD systems, these vehicles may not have had the passenger seat occupant sensing system calibration tested. Without passing the calibration test, the occupant sensing system may not operate as designed.
Remedy: Southeast Toyota will notify owners, and dealers will test the sensitivity of the occupant detection sensors, and recalibrate them as necessary. The recall began on March 21, 2013. Owners may contact Southeast Toyota at 1-800-301-6859.
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2008-2010 HIGHLANDER, MODEL YEAR 2009-2010 COROLLA, VENZA AND MATRIX PASSENGER VEHICLES. THE ACCELERATOR PEDAL CAN GET STUCK IN THE WIDE OPEN POSITION DUE TO ITS BEING TRAPPED BY AN UNSECURED OR INCOMPATIBLE DRIVER'S FLOOR MAT. THIS RECALL IS AN EXPANSION OF A CAMPAIGN OF 3.8 MILLION OTHER TOYOTA VEHICLES ANNOUNCED IN 2009 FOR THE SAME ISSUE (SEE 09V-388).
Remedy: TOYOTA WILL MODIFY OR REPLACE THE ACCELERATOR PEDALS ON THE SUBJECT VEHICLES. FLOOR SURFACE MODIFICATIONS ARE ALSO BEING CONSIDERED AND WILL BE INCLUDED FOR ANY MODEL FOR WHICH IT IS DEEMED APPROPRIATE. INITIALLY, DEALERS WILL BE INSTRUCTED ON HOW TO RESHAPE THE ACCELERATOR PEDAL FOR THE REPAIR. AS REPLACEMENT PARTS WITH THE SAME SHAPE AS THE MODIFIED PEDAL BECOME AVAILABLE, THEY WILL BE MADE AVAILABLE TO THE DEALERS FOR THE REPAIR. CUSTOMERS WHO HAVE HAD THE PEDAL RESHAPE REMEDY COMPLETED WILL HAVE THE OPPORTUNITY TO RECEIVE A NEW PEDAL IF THEY DESIRE, AFTER REPLACEMENT PEDALS BECOME AVAILABLE. IN ADDITION, TOYOTA WILL REPLACE ANY TOYOTA ALL-WEATHER FLOOR MAT IN A SUBJECT VEHICLE WITH A NEWLY DESIGNED MAT, FREE OF CHARGE. FOR THOSE CUSTOMERS WHO HAVE THE PREVIOUS DESIGN ALL-WEATHER FLOOR MAT BUT DO NOT NEED OR WANT THE NEWLY DESIGNED ALL-WEATHER FLOOR MAT, TOYOTA WILL RECOVER THE PREVIOUS DESIGN ALL-WEATHER FLOOR MAT AND REIMBURSE ITS PRICE. THE SAFETY RECALL BEGAN MARCH 30, 2010. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.
SOUTHEAST TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2011 PASSENGER VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
Remedy: DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT SOUTHEAST TOYOTA AT 1-800-301-6859.
GULF STATES TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2010 VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD BETWEEN SEPTEMBER 1, 2005 AND JUNE 2, 2008 WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
Remedy: DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. DEALERS WILL ALSO CORRECT THE OWNER'S MANUAL. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT GULF STATES TOYOTA AT 713-580-3300.
Toyota is recalling certain model year 2006-2008 RAV4, 2006-2010 Yaris, 2008-2010 Highlander, and 2009-2010 Tacoma, Corolla, Corolla Matrix and General Motors Pontiac Vibe vehicles. In the affected vehicles, the steering column assembly contains electrical connections to the driver's airbag module housed in a spiral cable assembly, which includes a Flexible Flat Cable (FFC). Due to the shape and location of the FFC's retainer, the FFC could become damaged when the steering wheel is turned.
Remedy: Toyota will notify the Toyota vehicle owners, and General Motors will notify the Pontiac Vibe owners. Toyota sent owners an interim notification letter in May 2014 to advise owners of the recall. Toyota will mail owners a second letter when remedy parts are available. General Motors sent Pontiac Vibe owners an Interim letter on June 20, 2014 notifying them that parts are currently unavailable. General Motors sent notices to the Pontiac Vibe owners on September 15, 2014, that a remedy is available. The recall began on October 27, 2014. Owners may contact Toyota at 1-800-331-4331. Owners may contact General Motors at 1-800-762-2737.
Trouble codes owners mention
OBD-II codes that appear in NHTSA complaints about this car.
Specifications
Factory options offered for the 2009 model year, decoded from the NHTSA vPIC database. Individual vehicles have one of each.
How other years compare
Check your exact Highlander by VIN
Recalls and equipment differ between individual vehicles. Decode your VIN to see what applies to yours.
Open VIN decoderFrequently asked questions
Is the 2009 Toyota Highlander reliable?
NHTSA has 174 owner complaints and 10 recall campaigns on record for the 2009 Toyota Highlander. The most complained-about area is service brakes (20% of complaints).
At what mileage do 2009 Toyota Highlander problems usually appear?
Half of the complaints that mention mileage were filed at 68,760 miles or less.
Does the 2009 Toyota Highlander have open recalls?
10 recall campaigns have been issued, the latest concerning hybrid propulsion system: inverter. Check your specific vehicle by VIN - recall repairs are free at franchised dealers.
Source: NHTSA recall campaigns and owner complaints (public domain). Counts reflect reports on file and are not a defect rate.