2005 Chevrolet Corvette: problems, recalls and reliability
6 recalls and 532 owner complaints on record; the weakest area is exterior lighting (14% of complaints); the 2003 and 2004 model years look more trouble-free.
Data updated weekly · 1 new complaint in the last 90 days · latest recall May 2014
All counts are reports filed with NHTSA in the United States - US market only, not worldwide totals.
Common problems
Computed from 532 owner complaints filed with NHTSA for this exact model year.
“The contact owns a 2005 Chevrolet Corvette. The contact stated that while operating the vehicle, the low-beam headlights malfunctioned and failed to illuminate as needed. The contact stated that the failure was intermittent. The vehicle was taken to the local mechanic, who was unable to duplicate the failure. The vehicle was not repaired. The local dealer and manufacturer were notified of the failure and informed the contact that the VIN was not included in NHTSA Campaign Number: 14V251000 (ELECTRICAL SYSTEM, EXTERIOR LIGHTING). The contact stated that the vehicle had experienced the failure listed in the recall. The failure mileage was 123,000.”Owner report · Exterior Lighting · Aug 2026
“As I'm driving, the brakes are deployed "hard" without any action on my part. "CHECK ACTIVE HANDLING SYSTEM" shows up on the screen. I have not het had the vehicle inspected.”Owner report · Forward Collision Avoidance · Oct 2025
“Sometimes (intermittently), when I push the start button to start the car, it just makes a "click" sound, the car does not start and the steering wheel will lock and all other functions of the car will be disabled. "CHECK COLUM LOCK" will be displayed on the screen. I have to take a battery cable off to reset the software before I can once again start and drive the car.”Owner report · Unknown Or Other · Oct 2025
Show 7 more owner reports
“This lead to an injury accident which totaled the car. I have documentation stating that the recall was fixed, but after I moved to Germany with the Army, the recall regularly activated the active handling when not needed (e.g parking) but then when we started slipping, the active handling did not engage and we crashed, totaling the car. The airbags did not engage even though the car played pinball on both sides of the autobahn. If we were going any faster, we would have died.”Owner report · Air Bags · Dec 2024
“The contact owns a 2005 Chevrolet Corvette. The contact stated while driving 45 MPH, the headlights were flickering and then became inoperable. The fuse box was melted. There was smoke detected from underneath the hood. There were no warning lights illuminated. The contact stated that the failure was related to NHTSA Campaign Number: 14V251000 (Electrical System, Exterior Lighting). The vehicle was towed to a local dealer, where it was diagnosed that the fuse box needed to be replaced. The vehicle was not repaired. The manufacturer was contacted, and informed the contact that the part was no longer produced. The failure mileage was approximately 80,000.”Owner report · Exterior Lighting · Jun 2024
“steering wheel lock car cannot start and this can happen while driving and could cause a accident chevy knows of problem and has been recalled but has not solved the problem knowed as steering wheel lock”Owner report · Steering · Dec 2023
“The contact owns a 2005 Chevrolet Corvette. The contact stated that the low-beam headlight failed to function properly. The contact stated no warning light was illuminated. The contact took the vehicle to the local dealer, where it was diagnosed with needing the fuse box to be replaced. The vehicle was not repaired. Upon investigation, the contact associated the failure with NHTSA Campaign Number: 14V251000 (Electrical System, Exterior Lighting) however, the VIN was not included. The manufacturer had not been informed of the failure. The failure mileage was 30,458.”Owner report · Electrical System · Aug 2023
“I bought this2005 corvette 3months and when i park it in the garage it fills up with gas fumes and could spark a fire.I have investigated this problem and its related to the gas tanks plastic parts.”Owner report · Fuel/Propulsion System · Aug 2023
“The contact owns a 2005 Chevrolet Corvette. The contact stated while driving approximately 20-25 MPH down a steep hill, he depressed the brake pedal however, the vehicle failed to stop as needed. There was no warning light illuminated. The contact stated that the brakes failed. The contact stated that brake fluid was leaking from the vehicle. The contact then saw thick smoke coming from the vehicle. The vehicle was taken to an independent mechanic but was not diagnosed or repaired. The manufacturer was notified of the failure and informed the contact that the VIN was not under recall and that the report would not be covered. The failure mileage was approximately 92,000.”Owner report · Service Brakes, Hydraulic · Feb 2023
“Service Column Lock, Service Active Handling System. Engine shut down (off) happened and avoided collision. Contacted GM and refused to issue a TSB (#18-NA-346, issued November 14, 2018).”Owner report · Electrical System · Feb 2022
When filing, owners marked a crash in 11 of these complaints and injuries in 6 - self-reported to NHTSA, not verified accident statistics.
Recalls - 6 campaigns
CERTAIN PASSENGER VEHICLES MAY HAVE BEEN BUILT WITH A POWER STEERING HOSE THAT IS NOT TO SPECIFICATION. UNDER EXTREME STEERING MANEUVERS, SUCH AS TURNING THE STEERING WHEEL FULLY TO THE LEFT OR RIGHT WHILE BRAKING, THE HOSE MAY FRACTURE AND LEAK FLUID.
Remedy: DEALERS WILL INSPECT THE POWER STEERING HOSE(S) FOR TWO SUSPECT DATE CODES AND REPLACE THEM IF REQUIRED. THE RECALL WILL BEGIN ON OCTOBER 14, 2005. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, BUICK AT 1-866-608-8080, CADILLAC AT 1-866-982-2339, ISUZU AT 1-800-255-6727, OR HUMMER AT 1-800-732-5493.
CERTAIN PASSENGER VEHICLES WERE PRODUCED WITH ONE OR BOTH REAR BRAKE HYDRAULIC LINES THAT CAN COME IN CONTACT WITH OR BE AFFECTED BY HEAT FROM THE LEFT ENGINE EXHAUST MANIFOLD AND THE LEFT EXHAUST PIPE. THE BRAKE FLUID COULD REACH ELEVATED TEMPERATURES AND BOIL.
Remedy: DEALERS WILL (1) INSPECT THE LEFT ENGINE EXHAUST MANIFOLD CLIP FOR PROPER ALIGNMENT AND PLACEMENT ON THE BODY-MOUNTED STUD. IF INCORRECT, THEY WILL REPOSITION THE CLIP ON THE BRAKE LINES AND REINSTALL THE CLIP ON THE STUD; (2) THE DEALER WILL VERIFY THAT BOTH REAR BRAKE LINES HAVE THE PROPER CLEARANCE TO THE LEFT EXHAUST PIPE. THEY WILL REPOSITION THE LINES BY BENDING AS NECESSARY; (3) DEALERS WILL REMOVE THE MACHINING TAB FROM THE REAR DIFFERENTIAL HOUSING. ALSO, DEALERS ARE TO INSPECT THE BRAKE LINES FOR WEAR IN THESE RELATED AREAS AND REPAIR OR REPLACE IF THERE IS ANY SIGN OF WEAR-THROUGH ON THE NYLON OVERCOATING. THE RECALL BEGAN ON JANUARY 18, 2005. OWNERS SHOULD CONTACT CADILLAC AT 1-866-982-2239 OR CHEVROLET AT 1-800-630-2438.
General Motors LLC (GM) is recalling certain model year 2005-2007 Chevrolet Corvette vehicles manufactured March 29, 2004, through June 22, 2007. In the affected vehicles, the underhood bussed electrical center (UBEC) housing can expand and cause the headlamp low beam relay control circuit wire to bend. If the wire is repeatedly bent, it may fracture causing a loss of low beam headlamp illumination.
Remedy: GM will notify owners, and dealers will install a jumper wire to correct this condition, free of charge. The recall began January 2, 2015. Owners may contact Chevrolet customer service at 1-800-222-1020. GM's number for this recall is 13146. Note: Model year 2008-2013 Chevrolet Corvettes will be covered under customer satisfaction program number 14203 for the same issue.
ON CERTAIN 2005-2006 CHEVROLET CORVETTES EQUIPPED WITH PAINTED ROOFS, THE ADHESIVE BETWEEN THE ROOF PANEL AND THE FRAME MAY SEPARATE.
Remedy: DEALERS WILL INSPECT VEHICLES FREE OF CHARGE FOR POTENTIAL ROOF PANEL-TO- FRAME SEPARATION AND ADD THE SPECIFIED ADHESIVE FOAM OR REPLACE THE ROOF WITH ONE HAVING ADHESIVE FOAM. THE RECALL BEGAN ON OCTOBER 19, 2006. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438.
GENERAL MOTORS IS RECALLING CERTAIN MODEL YEAR 2005 THROUGH 2007 CORVETTE VEHICLES EQUIPPED WITH A REMOVABLE ROOF AND MODEL YEAR 2006 AND 2007 CORVETTE Z06 VEHICLES. THE ADHESIVE BETWEEN THE ROOF PANEL AND THE FRAME MAY SEPARATE. IF THERE IS A PARTIAL SEPARATION, THE DRIVER MAY NOTICE ONE OR MORE SYMPTOMS, SUCH AS A SNAPPING NOISE WHEN DRIVING OVER BUMPS, WIND NOISE, POOR ROOF PANEL FIT, ROOF PANEL MOVEMENT/BOUNCE WHEN A DOOR OR HATCH IS CLOSED, OR A WATER LEAK IN THE HEADLINER.
Remedy: DEALERS WILL INSTALL A NEW DESIGN ROOF PANEL FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN DURING APRIL 2010. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 OR AT WWW.GMOWNERCENTER.COM.
GM IS RECALLING CERTAIN MODEL YEAR 2005 AND 2006 CHEVROLET CORVETTE PASSENGER CARS MANUFACTURED BETWEEN MARCH 2004 AND JANUARY 2006 EQUIPPED WITH A TILT AND TELESCOPING STEERING COLUMN (RPO N37). IN RARE CASES, REPEATED MOVEMENT OF THE STEERING COLUMN MAY CAUSE A SIGNAL INTERRUPTION WITHIN THE COLUMN. IF THIS OCCURS, THE MESSAGE, "SERVICE ACTIVE HANDLING SYSTEM" WILL APPEAR IN THE DRIVER INFORMATION CENTER, AND ONE OR MORE OF THE BRAKES MAY APPLY, POSSIBLY CAUSING THE VEHICLE TO PULL TO THE RIGHT OR LEFT.
Remedy: GM WILL NOTIFY OWNERS AND DEALERS WILL REPAIR THE VEHICLES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON APRIL 30, 2010. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 AND GMC AT 1-866-996-9463 OR AT THE OWNER CENTER AT WWW.GMOWNERCENTER.COM.
Trouble codes owners mention
OBD-II codes that appear in NHTSA complaints about this car.
How other years compare
Check your exact Corvette by VIN
Recalls and equipment differ between individual vehicles. Decode your VIN to see what applies to yours.
Open VIN decoderFrequently asked questions
Is the 2005 Chevrolet Corvette reliable?
NHTSA has 532 owner complaints and 6 recall campaigns on record for the 2005 Chevrolet Corvette. The most complained-about area is exterior lighting (14% of complaints).
At what mileage do 2005 Chevrolet Corvette problems usually appear?
Half of the complaints that mention mileage were filed at 40,000 miles or less.
Does the 2005 Chevrolet Corvette have open recalls?
6 recall campaigns have been issued, the latest concerning steering:hydraulic power assist:hose, piping, and connections. Check your specific vehicle by VIN - recall repairs are free at franchised dealers.
Source: NHTSA recall campaigns and owner complaints (public domain). Counts reflect reports on file and are not a defect rate.