1996 Chevrolet C30: problems, recalls and reliability
6 recalls and 5 owner complaints on record; most reports concern service brakes, hydraulic.
Data updated weekly · latest recall Mar 1997
All counts are reports filed with NHTSA in the United States - US market only, not worldwide totals.
Common problems
Computed from 5 owner complaints filed with NHTSA for this exact model year.
“The ABS braking system malfunctioned when applying the brakes hard and quickly. Had an accident, applied the brakes quickly and they malfunctioned, causing the vehicle to roll 30 feet and run into another vehicle. Dealer said that was how the brakes worked. *ak”Owner report · Service Brakes, Hydraulic · Feb 1997
“Vehicle used for police use. Consumer stated when traveling at 30 mph the rear brakes grab and also lock up, causing the vehicle to freeze. Consumer also stated when the problem occurs the occupants inside the vehicle being forced into the windshield. Consumer has contacted the dealer. *ak”Owner report · Service Brakes, Hydraulic · Jul 1996
“I have a recall letter from gm canada concerning antilock brakes. When I took the van to be fixed, the dealer would not do it because the van was converted to an rv by roadtrek and it would require 16 hours labor to repair the brakes. Neither gm or roadtrek would cover the cost. How can I get this resolved.”Owner report · Service Brakes, Hydraulic
When filing, owners marked a crash in 2 of these complaints and injuries in 0 - self-reported to NHTSA, not verified accident statistics.
Recalls - 6 campaigns
THE FOUR U-BOLTS NUTS ON EITHER SIDE OF THE REAR AXLE WERE UNDER-TORQUED.
Remedy: DEALERS WILL CHECK THE U-BOLT NUT TORQUE AND RE-TORQUE ANY LOOSE U-BOLTS TO SPECIFICATION.
VEHICLE DESCRIPTION: EXTENDED CAB AND 2-DOOR UTILITY VEHICLES EQUIPPED WITH RECLINING SEATS AND THE EASY-ENTRY FEATURE. THESE VEHICLES EXHIBIT A CONDITION IN WHICH A PINCH POINT EXISTS IN THE RECLINER MECHANISM THAT CAN TRAP AND PINCH A PERSON'S HAND OR FINGER(S) WHEN THE EASY-ENTRY FEATURE IS ACTIVATED.
Remedy: DEALERS WILL INSTALL A PROTECTOR COVER OVER THE RECLINER MECHANISM.
THE SEAT RECLINER TO SEAT FRAME ATTACHING BOLTS ON THESE VEHICLES COULD LOOSEN, FATIGUE AND FRACTURE, ALLOWING THE SEAT BACK TO SUDDENLY RECLINE.
Remedy: DEALERS WILL REMOVE ALL FOAM AND/OR FABRIC SANDWICHED BETWEEN THE RECLINER ASSEMBLY AND THE SEAT FRAME, INSTALL WASHERS BETWEEN THE SEAT RECLINER AND THE SEAT FRAME AT EACH ATTACHMENT POINT, AND INSTALL NEW ATTACHING BOLTS TORQUED TO A HIGHER SPECIFICATION. THESE CORRECTIONS WILL BE MADE TO BOTH THE DRIVER'S AND PASSENGER'S SEATS.
THESE TIRES HAVE BEAD DAMAGE WHICH OCCURED DURING TIRE MOUNTING.
Remedy: DEALERS WILL DEMOUNT EACH TIRE AND INSPECT FOR BEAD DAMAGE. IF BEAD DAMAGE IS FOUND, THE TIRE WILL BE REPLACED.
CERTAIN TRUCKS HAVE FUEL RAIL ASSEMBLIES WITH AN IMPROPERLY CRIMPED END RETAINER CLIP THAT RESULTS IN A FUEL LEAK.
Remedy: DEALERS WILL INSPECT THE FUEL RAIL ASSEMBLY AND REPLACE ANY FUEL RAIL ASSEMBLY WITH A JULIAN DATE CODE OF 95318 THROUGH 95338.
THESE VEHICLES WERE ASSEMBLED WITH THE THROTTLE CABLE CONTACTING THE DASH MAT WHICH COULD BIND THE THROTTLE. THIS DOES NOT MEET WITH THE MAXIMUM RETURN TIMES REQUIRED BY FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 124, "ACCELERATOR CONTROL SYSTEMS."
Remedy: DEALERS WILL INSPECT FOR ADEQUATE THROTTLE CABLE TO DASH MAT CLEARANCE, AND IF THERE IS INSUFFICIENT CLEARANCE, CUT OUT A PORTION OF THE DASH MAT TO PROVIDE PROPER CLEARANCE.
How other years compare
Check your exact C30 by VIN
Recalls and equipment differ between individual vehicles. Decode your VIN to see what applies to yours.
Open VIN decoderFrequently asked questions
Is the 1996 Chevrolet C30 reliable?
NHTSA has 5 owner complaints and 6 recall campaigns on record for the 1996 Chevrolet C30. The most complained-about area is service brakes, hydraulic.
Does the 1996 Chevrolet C30 have open recalls?
6 recall campaigns have been issued, the latest concerning suspension:rear:springs:leaf spring assembly:u-bolt, leaf spring to axle. Check your specific vehicle by VIN - recall repairs are free at franchised dealers.
Source: NHTSA recall campaigns and owner complaints (public domain). Counts reflect reports on file and are not a defect rate.