2003 Volkswagen Passat: problems, recalls and reliability
7 recalls and 637 owner complaints on record; the weakest area is fuel system, gasoline (19% of complaints); the 2004 and 2005 model years look more trouble-free.
Data updated weekly · latest recall Jun 2018
All counts are reports filed with NHTSA in the United States - US market only, not worldwide totals.
Common problems
Computed from 637 owner complaints filed with NHTSA for this exact model year.
“The contact owns a 2003 Volkswagen Passat. The contact stated while driving at an undisclosed speed, the vehicle stalled. There were no warning lights illuminated. The vehicle was taken to the dealer, where it was diagnosed and determined that the fuel pump needed to be replaced. The manufacturer was made aware of the failure and informed the contact that the parts needed for the repair could not be found. The vehicle was not repaired. The contact related the failure to NHTSA Campaign Number: 07V375000 (Fuel System, Gasoline); however, the VIN was included but the vehicle was not repaired. The failure mileage was approximately 133,000.”Owner report · Fuel System, Gasoline · Nov 2025
“The contact owns a 2003 Volkswagen Passat. The contact received notification of NHTSA Campaign Number: 06V017000 (Fuel System, Gasoline); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was made aware of the issue and confirmed that parts were not yet available. The manufacturer was made aware of the issue and confirmed that parts were not yet available. The contact had not experienced a failure. Parts distribution disconnect.”Owner report · Fuel System, Gasoline · Mar 2025
“Vehicle has major fuel pump issue, currently at 132,000 and noticing loss of power, car shaking, and occasional stall. A code reader is unable able to detect the issue which is a major concern. I have contacted the volkswagen Manufacturer and I consistently keep getting ignored after bringing up the recall that was put out for the fuel pump. While driving on the highway my rear and front suspension failed and dropped suddenly while moving slowly during traffic. I whave only been able to repair the front shocks and struts so far, but the rear are needed as well. I would like to state that all the parts are original manufacturer parts.”Owner report · Fuel/Propulsion System · Dec 2022
Show 7 more owner reports
“The contact owns a 2003 Volkswagen Passat. The contact stated that while driving approximately 35 mph the vehicle's speed suddenly begin to reduce and smoke was present coming from the engine compartment. After stopping and exiting the vehicle became engulfed in flames. The fire department was called to the scene and extinguished the flames and the vehicle was towed away. During the incident, the vehicle was destroyed. The local dealer and manufacturer were notified of the incident but no assistance was offered. The failure mileage was 150,000.”Owner report · Engine · Sep 2021
“I purchased a used 2003 vw passat from a private dealer drove the car five months and the timing belt came off while I was driving. I almost got into an accident but avoided it. This particular vehicle and ones like it was recalled in 3/7/2014 for engine and engine cooling engine problems that causes the timing belt to come off while driving. Recall: 14e007000 because of the timing belt failure. I contacted a vw dealership and they said the recall didn't apply to my car. I find that insulting consider ing what I just experienced.”Owner report · Fuel/Propulsion System · May 2021
“My son was driving (in motion) on hwy 17 in miller county mo with seat heater on saturday nov. 28, 2020. Seat caught on fire. I had noticed when I had seat heater on previously it became so hot as to burn legs. This is a serious problem. It could have burned my car completely. Very dangerous.”Owner report · Seats · Nov 2020
“Fuel tank leaking when full on drivers side directly under rear passenger seat. Which happens to be where my children sit. It leaks until it's a little over half full then stops.”Owner report · Fuel/Propulsion System · Jan 2020
“Tl* the contact owns a 2003 volkswagen passat. The contact stated while the vehicle was at a stand still, the vehicle failed to start. The contact stated that the check engine warning light was illuminated. The vehicle was taken to independent mechanic to be diagnosed. The contact was informed that the timing chain actuator/solenoid needed to be replaced. The contact stated a local dealer was contacted about open recalls and stated that there was no recall on vehicle. The vehicle had not been repaired as of yet. The manufacturer was made aware of the failure. The failure mileage was approximately 180,000.”Owner report · Engine · Aug 2019
“05/01/2019 car had a dead battery---charge over night still would not start---had the car towed to auto shop--upon arrival with key on approx. 15 min drive--smoke started billowing---disconnected battery---drivers side seat warmer completely melted--mechanic says unit pulling 30 amps--there was a previous recall--not sure if totally corrected--donot want to replace immediately--please advise”Owner report · Seats · May 2019
“Tl* the contact owns a 2003 volkswagen passat. The contact stated that the vehicle would not hold fuel and the tank had to constantly be refilled. Also, the check engine warning indicator illuminated. The vehicle was taken to ellis motorcars inc (2235 e south blvd, montgomery, al 36116, (334) 280-1021) where it was diagnosed that the coolant system and the timing chain needed to be repaired. The vehicle was not repaired. The manufacturer was made aware of the failure and did not assist. The failure mileage was 78,000.”Owner report · Engine · Feb 2019
When filing, owners marked a crash in 14 of these complaints and injuries in 47 - self-reported to NHTSA, not verified accident statistics.
Recalls - 7 campaigns
The Gates Corporation (Gates) is recalling certain aftermarket Tru-Flow Water Pumps, part number TFW 41127, sold at certain NAPA Auto Parts and/or installed by automotive service technicians after November 1, 2013 (and manufactured August 2013 through October 2013) that have a black-colored pulley/sprocket or do not have 'US9377' stamped on the water pump housing. These service replacement parts were sold for use in model year 1999-2005 Audi A4, 2000-2006 Audi TT, 1998-2005 Volkswagen Beetle, 1999-2006 Golf, 1999-2008 and 2011-2013 Volkswagen Jetta, and 2000-2005 Volkswagen Passat. In the affected water pumps, the pulley or sprocket that turns the timing belt may develop microfractures causing the timing belt to fail.
Remedy: Gates will notify owners, and dealers will replace the water pump, free of charge. The recall began during May 2014. Owners may contact The Gates Corporation at 1-303-744-1911.
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2003 Volkswagen Passat sedan, Jetta, Jetta wagon, Golf, EuroVan, EuroVan Camper Van and EuroVan Chassis vehicles. Upon deployment of the driver's frontal air bag, excessive internal pressure may cause the inflator to explode.
Remedy: Volkswagen will notify owners, and dealers will replace the driver's frontal air bag inflator, free of charge. The recall began May 2, 2019. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 69X3.
ON CERTAIN VEHICLES PRODUCED FROM SEPTEMBER 2002 - MARCH 2003, EQUIPPED WITH 1.8L TURBO, 2.8L V6, OR 3.0L ENGINES, A CHANGE IN THE ELECTRICAL MOTOR COMPONENTS IN THE FUEL PUMP CAN LEAD TO AN INOPERATIVE FUEL PUMP AND, ULTIMATELY, STOPPAGE OF FUEL SUPPLY TO THE ENGINE CAUSING IT TO STALL.
Remedy: DEALERS WILL INSTALL NEW FUEL PUMPS FREE OF CHARGE. THE RECALL BEGAN ON APRIL 10, 2006. OWNERS MAY CONTACT VW AT 1-800-222-8987 OR AUDI AT 1-800-822-2834.
ON SOME PASSENGER VEHICLES, THE FUEL TANK FILLER NECK CAN SUFFER ABRASION DAMAGE IF THE REAR TIRE GOES FLAT AND THE VEHICLE IS DRIVEN UNTIL THE TIRE DISINTEGRATES.
Remedy: DEALERS WILL FIT PASSAT VEHICLES WITH A NEW WHEEL HOUSE LINER THAT WILL BETTER PROTECT THE CAR'S FILLER NECK. JETTA VEHICLES WILL BE FITTED WITH A DIFFERENT METAL SHIELD DESIGNED TO ENHANCE ABRASION PROTECTION IN THE EVENT OF TIRE DISINTEGRATION. OWNER NOTIFICATION BEGAN JUNE 13, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT VOLKSWAGEN AT 1-800-822-8987.
ON CERTAIN PASSENGER, WAGON, AND CONVERTIBLE VEHICLES EQUIPPED WITH OR WITHOUT CRUISE CONTROL, A BRAKE LIGHT SWITCH MAY MALFUNCTION IF IT WAS INSTALLED INCORRECTLY.
Remedy: DEALERS WILL INSTALL THE NEWLY DESIGNED BRAKE LIGHT SWITCH FREE OF CHARGE. THE RECALL BEGAN ON APRIL 27, 2007, AND WILL BE CONDUCTED IN SEVERAL STAGGERED MAILINGS THROUGH SEPTEMBER 21, 2007. VEHICLES WITHIN THE MAKE, MODEL, AND MODEL YEAR OF THIS POPULATION MAY BE INVOLVED IN EITHER THIS RECALL OR 06V-183, BUT NOT BOTH. THE REMEDY IS THE SAME FOR EACH RECALL. VOLKSWAGEN DEALERS WILL APPLY THE REMEDY BASED ON THE VIN NUMBER OF THE VEHICLE. OWNERS MAY CONTACT VW AT 1-800-822-8987.
ON CERTAIN VEHICLES EQUIPPED WITH 1.8L TURBO, 2.8L V6, OR 3.0L ENGINES, A CHANGE IN THE ELECTRICAL MOTOR COMPONENTS IN THE FUEL PUMP CAN LEAD TO AN INOPERATIVE FUEL PUMP AND, ULTIMATELY, STOPPAGE OF FUEL SUPPLY TO THE ENGINE CAUSING IT TO STALL.
Remedy: DEALERS WILL INSTALL NEW FUEL PUMPS FREE OF CHARGE. THE RECALL BEGAN ON SEPTEMBER 28, 20007. OWNERS MAY CONTACT VW AT 1-800-222-8987 OR AUDI AT 1-800-822-2834. THIS RECALL IS A SUPPLEMENT TO A PREVIOUS CAMPAIGN (PLEASE SEE 06V017).
VOLKSWAGEN IS RECALLING 412,000 MY 1999-2005 PASSAT (5TH GENERATION) VEHICLES EQUIPPED WITH AUTOMATIC TRANSMISSIONS AND PRODUCED AFTER JUNE 14, 1999. THESE VEHICLES MAY HAVE AN UNDERBODY HEAT SHIELD THAT CAN BECOME DAMAGED. IN ADDITION, AFFECTED VEHICLES WITH AUTOMATIC OR MANUAL TRANSMISSIONS MAY HAVE A FUEL LINE (1.8T ENGINES ONLY) OR FUEL TANK VENTILATION VALVE (4MOTION/ALL WHEEL DRIVE ONLY) THAT CAN LEAK DUE TO FRACTURE.
Remedy: DEALERS WILL INSTALL ADDITIONAL UNDERBODY HEAT SHIELDS ON VEHICLES WITH AUTOMATIC TRANSMISSIONS TO COVER THE POSSIBLY DAMAGED AREAS AND FLASH ALL 1.8T ENGINES WITH A PRECAUTIONARY SOFTWARE UPDATE. DEALERS WILL ALSO INSPECT AND ADJUST THE FUEL LINE ROUTING ON 1.8T VEHICLES AND THE FUEL TANK VENTILATION VALVE ON 4MOTION/ALL WHEEL DRIVE VEHICLES, AND REPLACE COMPONENTS IF NECESSARY FREE OF CHARGE. THE RECALL BEGAN ON JUNE 13, 2008. OWNERS MAY CONTACT VOLKSWAGEN AT 1-800-822-8987.
Specifications
Factory options offered for the 2003 model year, decoded from the NHTSA vPIC database. Individual vehicles have one of each.
How other years compare
Check your exact Passat by VIN
Recalls and equipment differ between individual vehicles. Decode your VIN to see what applies to yours.
Open VIN decoderFrequently asked questions
Is the 2003 Volkswagen Passat reliable?
NHTSA has 637 owner complaints and 7 recall campaigns on record for the 2003 Volkswagen Passat. The most complained-about area is fuel system, gasoline (19% of complaints).
At what mileage do 2003 Volkswagen Passat problems usually appear?
Half of the complaints that mention mileage were filed at 59,641 miles or less.
Does the 2003 Volkswagen Passat have open recalls?
7 recall campaigns have been issued, the latest concerning engine and engine cooling:engine. Check your specific vehicle by VIN - recall repairs are free at franchised dealers.
Source: NHTSA recall campaigns and owner complaints (public domain). Counts reflect reports on file and are not a defect rate.