2002 Dodge Ram 1500: problems, recalls and reliability
6 recalls and 815 owner complaints on record; the weakest area is structure (34% of complaints); the 2000 model year looks more trouble-free.
Data updated weekly · latest recall Aug 2010
All counts are reports filed with NHTSA in the United States - US market only, not worldwide totals.
Common problems
Computed from 815 owner complaints filed with NHTSA for this exact model year.
“Dodge Ram 2002 ABS brake module failure. No recourse for repairs. Dodge has rendered this part obsolete and although they have the technology to repair or replace it they neglect to help thousands of vehicle owners.”Owner report · Service Brakes · Oct 2024
“The contact owns a 2002 Dodge Ram 1500. The contact stated that while driving at an undisclosed speed at night, he became aware that the external lights and turn signal lights were not functioning properly. The lamp out warning light was illuminated. The vehicle was not taken to the dealer or an independent mechanic. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was unknown.”Owner report · Exterior Lighting · Jun 2024
“To put it as simple as I can describe it is a death wobble. that occurs every time you hit a bump in the road, hole, or pot hole. This truck has always had this death wobble from factory. The reason why this is a safety issue is because it causes the steering wheel to go out of balance and go into other lanes in the road and potentially cause an accident.”Owner report · Suspension · Jul 2023
Show 7 more owner reports
“The heat stopped working so i replaced the blower motor and blower relay the heater switch and still have no heat. The wire gets hot to the touch. The heater only use to work on high then all of a sudden it just stopped all the way around”Owner report · Electrical System · Mar 2023
“I was driving on the highway at about 65mph and at first I noticed that it felt like my tie rod ends were going bad. And then all of a sudden I felt an explosion and my truck made a sharp right dive into the right hand lane and caused the car in that lane to swerve right. I was then able to gain back control and gradually came to a stop on the right hand berm of the highway. The right rear tire appeared just as it does in the attached photos. The tire size is p264/70R17 no authorities were notified and the tire has not been inspected by anyone.”Owner report · Tires · May 2022
“While traveling at normal speeds approximately 40 mph a car ran a stop sign I t-boned them on their passenger side with my front end I hit them at approximately 40 mph my airbags did not deploy my face and chest hit the steering wheel and dash”Owner report · Air Bags · Oct 2021
“2002 dodge ram 1500 4x4 5.9l was driving dow hey 10 when my back tries locked up couldn't get it in gear or out almost crash when got it on to side of road and stopped when it finally was able to go in a gear it was reverses and it would just make this god awful grinding nose truck was towed back home”Owner report · Power Train · Feb 2021
“The beam under the bed of the truck is breaking apart. No other part under the truck had this prob. No corrosion any other place but the beam of the truck”Owner report · Structure · Jul 2020
“Hello, I have had a problem with my dodge ram the fuel line system just cracked and caused my vehicle to catch fire and blow up while myself in my 7 year old granddaughter was in the vehicle my vehicle has been maintained since day one when I bought it brand new never having problems with it other than your will wells were never drilled out to drain the water in the back I would like to know if you have had other issues with this vehicle on the same incident. Myself in my granddaughter inhale very toxic fumes before we were able to get out the truck as it was on fire and inches away when it exploded.pics and report wont download thank you”Owner report · Engine · Jun 2019
“Tried to get the truck started and could not get it to work. Took the keys out and throw them up on the dash and the truck started and all electronical stuff in truck came on. Then when driving home it would rev up and down and would try to shut off when I had to stop”Owner report · Electrical System · May 2019
When filing, owners marked a crash in 55 of these complaints and injuries in 62 - self-reported to NHTSA, not verified accident statistics.
Recalls - 6 campaigns
CERTAIN REPLACEMENT K&N FUEL PERFORMANCE KITS, P/NOS. 57-1509, 57-1511, 57-1511-1, 57-1517, 57-1517-1, 57-1527, AND 57-1530. ALSO, A SMALL PERCENTAGE OF THESE KITS WERE SOLD UNDER THE MOPAR PERFORMANCE PARTS BRAND NAME (P/NOS. P5007069 AND P5007070). ALL KITS WERE MANUFACTURED FROM APRIL 20, 1999, THROUGH SEPTEMBER 23, 2004. THESE ASSEMBLIES WERE MANUFACTURED AS REPLACEMENT EQUIPMENT FOR CERTAIN DODGE PICKUP TRUCKS AND SUVS. A SMALL PIECE OF MATERIAL FROM THE TUBE WALL COULD BE SUCKED INTO THE ENGINE THROTTLE BODY, WHICH COULD CAUSE THE THROTTLE TO BECOME JAMMED IN THE OPEN POSITION.
Remedy: K&N WILL PROVIDE OWNERS WITH A FREE REPAIR KIT ALONG WITH REPAIR INSTRUCTIONS. THE RECALL BEGAN ON APRIL 20, 2006.
ON CERTAIN PICKUP TRUCKS, THE DETENT SYSTEM ON THE EXTERIOR MIRROR HOUSINGS MAY LOSE THE FUNCTIONALITY.
Remedy: DEALERS WILL INSTALL A MIRROR DETENT RETAINER KIT TO CORRECT THIS CONDITION. OWNER NOTIFICATION BEGAN ON APRIL 10, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
ON CERTAIN PICKUP TRUCKS, THE ELECTRICAL CONNECTOR AT THE BOTTOM OF THE STEERING COLUMN CONTAINS AN UNDER-SIZED TERMINAL FOR THE HVAC BLOWER MOTOR CIRCUIT. LOCALIZED HEATING FROM CURRENT FLOW WITH THE BLOWER SPEED SET ON HIGH MAY CAUSE THE TERMINAL CONTACTS TO RELAX AND LOSE ELECTRICAL CONTACT. THIS CAN CAUSE THE HVAC BLOWER MOTOR TO BECOME INOPERATIVE.
Remedy: DEALERS WILL INSTALL A WIRING HARNESS OVERLAY TO CORRECT THIS CONDITION. OWNER NOTIFICATION BEGAN APRIL 15, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
CERTAIN CURVED TEMPERED REPLACEMENT GLASS MANUFACTURED BY HANGZHOU SAFETY GLASS LTD AND SUPPLIED TO SAFELITE BY AUTO TEMP INC., IDENTIFIED AS DOT-430, AND SOLD FOR USE ON CERTAIN DOMESTIC AND FOREIGN VEHICLES MAY NOT BREAK INTO SMALL PIECES AS EXPECTED OF TEMPERED GLASS AND FAILS TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 205, "GLAZING MATERIALS."
Remedy: SAFELITE WILL NOTIFY ITS RETAIL CUSTOMERS AND REPLACE THE GLASS FREE OF CHARGE. RETAIL CUSTOMERS CAN CONTACT SAFELITE TOLL FREE AT 1-888-843-2906. SAFELITE WILL NOTIFY ITS WHOLESALE CUSTOMERS AND REIMBURSE WHOLESALE CUSTOMERS FOR CURRENT INVENTORY AND AT A SPECIFIED RATE FOR REPLACING THEIR CUSTOMER'S GLASS. WHOLESALE CUSTOMERS CAN CONTACT SAFELITE'S WHOLESALE DIVISION, SERVICE AUTOGLASS TOLL FREE AT 1-888-246-6298. THE RECALL BEGAN ON JANUARY 15, 2008.
ON CERTAIN 4X4 PICKUP TRUCKS EQUIPPED WITH THE SNOW PLOW PREPARATION PACKAGE, THE TIRES SUPPLIED ON SOME VEHICLES MAY HAVE GROSS AXLE WEIGHT RATINGS THAT SLIGHTLY EXCEED THE MAXIMUM TIRE LOAD CAPACITY AS DEFINED IN FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 120, "TIRE SELECTION AND RIMS FOR MOTOR VEHICLES OTHER THAN PASSENGER CARS."
Remedy: DEALERS WILL PROVIDE REPLACEMENT P245/75R16 TIRES TO MEET THE LOAD CARRYING CAPACITY SPECIFIED ON THE VEHICLE CERTIFICATION LABEL AND ACCOMMODATE THE ADDITION OF A COMMERCIALLY AVAILABLE SNOW PLOW AND HARDWARE. OWNER NOTIFICATION BEGAN ON DECEMBER 22, 2003. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-992-1997.
FEDERAL-MOGUL IS RECALLING CERTAIN CARQUEST, NATIONAL, AND PERCISION BRAND WHEEL HUB ASSEMBLIES, P/NOS 515073 AND 515073, SOLD FOR USE AS REPLACEMENT EQUIPMENT ON MODEL YEAR 2002 THROUGH 2008 DODGE RAM 1500 PICKUP TRUCKS. THE INBOARD ROLL FORM USED TO MAINTAIN THE HUB ASSEMBLY CAN FATIGUE RESULTING IN NOISE AND/OR WHEEL SEPARATION ON THE TWO WHEEL DRIVE (2WD) APPLICATIONS. THE RISK OF THESE ISSUES DO NOT OCCUR ON THE FOUR WHEEL DRIVE (4WD) APPLICATIONS, AND INSTALLATION ON THE 4WD APPLICATIONS ARE NOT PART OF THIS RECALL.
Remedy: FEDERAL-MOGUL WILL NOTIFY OWNERS OF RECORD AND TECHNICIANS WILL REPLACE THE AFFECTED HUB ASSEMBLIES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON SEPTEMBER 15, 2010. OWNERS MAY CONTACT FEDERAL-MOGUL AT 1-877-489-6659.
How other years compare
Check your exact Ram 1500 by VIN
Recalls and equipment differ between individual vehicles. Decode your VIN to see what applies to yours.
Open VIN decoderFrequently asked questions
Is the 2002 Dodge Ram 1500 reliable?
NHTSA has 815 owner complaints and 6 recall campaigns on record for the 2002 Dodge Ram 1500. The most complained-about area is structure (34% of complaints).
At what mileage do 2002 Dodge Ram 1500 problems usually appear?
Half of the complaints that mention mileage were filed at 72,000 miles or less.
Does the 2002 Dodge Ram 1500 have open recalls?
6 recall campaigns have been issued, the latest concerning engine and engine cooling. Check your specific vehicle by VIN - recall repairs are free at franchised dealers.
Source: NHTSA recall campaigns and owner complaints (public domain). Counts reflect reports on file and are not a defect rate.