2006 Chrysler 300C: problems, recalls and reliability

“gasket around fuel pump failed allowing gas to pool on top of fuel tank under the back seat on passenger side . this resulted in a strong "gas/fuel" smell from fuel vapors colecting inside the car and the obvious risk of ignition/explosion and negative health effects of breathing said fumes .the vehicle has not been inspected yet because we are afraid to start the vehicle let alone drive it to the shop . We are making araingements to have it towed to the repair shop . we have not had any warning lights . Mechanic said it was a common problem with seal failure around fuel pump . the vehicle has 127,000 miles”Owner report · Fuel/Propulsion System · Jan 2025

“Car will buck/jerk at higher speeds, will also die at low speeds or idle, will fall on its face when trying full throttle, the oil light, check engine light, Limp mode will flash sometimes traction control, esp will flash most the time the 2 lights stay on Problem has been confirmed by 2 dealers. Puts my saftry at risk because engine will js die at 20mph i lose brakes and steering. Problem first appeared about the beginning of this year when my camshaft went out but wasn't showing a code for a month and a half then gave me a code since then ive had this problem Vehicle has not been inspected”Owner report · Electrical System · Jan 2025

“While I was driving the car, the car stalled on me at a stop light, its a safety risk and could caused an accident at anytime, yes its available for inspection. Yes the problem has been reported and inspected by auto shop and dealership. No warning lights it just randomly happened while driving, while I was driving the check engine light popped up then disappeared and 2mintues later my car power was reduced and car shutoff at stoplight.”Owner report · Electrical System · Dec 2023

“Once fueled, the engine will consistently stall from start to cruising speed, and has even shut off while driving. There was an issue with Chrysler fuel tanks evap valve sticking open, which causes this fault, however I have not received any assistance from Chrysler or any authorized dealer.”Owner report · Fuel/Propulsion System · Oct 2023

“My Fuel Tank is stuck in open position, it is making my car stall, sputter, and cut off. When my gas is very low car doesn't cut off and runs fine, but when I fill car up it stalls and cuts off, this is very dangerous it cuts off at red lights, stop signs, slow traffic, I've seen this is a Warranty/Recall problem with the faulty fuel tanks, with stuck open fuel shutoff valve. My car is running at max fuel because of this problem. It's been like this since I bought car 2 months ago. I need this fixed immediately. And all parts on my car are brand new this Faulty fuel tank is the Culprit”Owner report · Fuel/Propulsion System · Oct 2023

“The contact owns a 2006 Chrysler 300C. The contact stated that while driving at slow speeds during traffic congestion, the vehicle inadvertently lost motive power and stalled. Upon restarting the vehicle, the vehicle hesitated but seemed to return to normal functionality. No warning lights were illuminated. The vehicle was taken to the dealer however, the dealer was unable to determine the cause of the failure. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was 200,000.”Owner report · Power Train · Jun 2023

“The car will just shut off while driving or at rest. My safety and other people on the road is unsafe in the vehicle because when it shuts off in the middle of the road the steering wheel is also not working. The car has been to multiple shops with each shop guessing what could be the problem and fixing what they think may be wrong and after 2,000 dollars the car is still stalling out while being drove. No lights or diagnostic test come up with anything that could cause the problem”Owner report · Fuel/Propulsion System · May 2023