2022 Chevrolet Bolt: problems, recalls and reliability
7 recalls and 59 owner complaints on record; the weakest area is electrical system (40% of complaints).
Data updated weekly · latest recall Oct 2024
All counts are reports filed with NHTSA in the United States - US market only, not worldwide totals.
Common problems
Computed from 59 owner complaints filed with NHTSA for this exact model year.
“I was was traveling at 68 mph, then rear ended and pushed into the center divide. The entire front drivers tire + assembly was destroyed. The airbags didn't deploy. The cab did fill with a white 'smoke'. A little bit later I received a message from the Chevy app that there was a problem with my airbags and I should seek service. My insurance has deemed the car a total loss and picked up the car and taken it to their lot for inspection. I don't know the status of this and the incident has not been reported to the manufacturer/dealer.”Owner report · Air Bags · Sep 2025
“The contact owns a 2022 Chevrolet Bolt EV. The contact stated that while driving at various speeds, the vehicle lost automotive power, and the digital screen failed to display as intended. The Battery warning light was occasionally illuminated during rainy weather. The local dealer was contacted. The vehicle was not diagnosed or repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 65,000.”Owner report · Electrical System · Sep 2024
“I was driving 72 mph, and went to accelerate to 75 mph to set my cruise control. As soon as I stepped on the accelerator pedal, my 2022 Chevy Bolt EUV jerked violently and immediately applied braking to car to take it from 72 mph to about 30 mph within 1 second. Had someone been behind me I would have been rear ended. I was able to pull over to the shoulder of the road, and put my car into park. I was unable to turn off the vehicle or shift into any gears (reverse, neutral, drive). The car displayed a warning on dash "power drive train malfunction pull over safely". There was no warning for the sudden deceleration and is a serious safety risk and concern.”Owner report · Service Brakes · Jan 2024
Show 7 more owner reports
“When I use the windshield washer fluid some of the vapors gets in the cabin. The fluid contains methanol and it is highly toxic.”Owner report · Unknown Or Other · Dec 2023
“2022 Chevy Bolt, less than 10,000 miles. Problem began 11/24/23. Steering wheel locks up at low speeds, gives warning "Steering Assistance reduced" at higher speeds. At low speeds, steering wheel turns only a small amount before it clicks and stops. Very dangerous in tight parking lots or trying to turn left or right from a stop - takes multiple tries to get steering wheel to turn, and sometimes it jerks back in the opposite direction. Took it to dealer, they said steering column needs to be replaced. Did not have an accident or hit anything prior - I think the column is defective.”Owner report · Steering · Nov 2023
“Vehicle stopped while driving down the road lost power threw up multiple codes and was stuck in the middle of the roadway!”Owner report · Fuel/Propulsion System · Oct 2023
“The contact owns a 2022 Chevrolet Bolt EV. The contact received notification of NHTSA Campaign Number: 23V567000 (Air Bags, Electrical System) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was made aware of the issue and confirmed that parts were not yet available. The manufacturer was made aware of the issue and confirmed that parts were not yet available. The contact had not experienced a failure. VIN tool confirms parts not available.”Owner report · Electrical System · Sep 2023
“Complete transmission failure shortly after seeing "Service Transmission" message in 2022 Chevy Bolt EV Drivers Information Center. When message first appeared selected option to dismiss message and continued to drive as normal. After turning vehicle off and then back on the message appeared again and all attempts to change gear into neutral, reverse, or drive resulting in all doors unlocking and the vehicle shifting back into park. Was unable to put car in neutral and move vehicle off road therefore blocking traffic until a tow truck arrived 90 minutes later.”Owner report · Electrical System · Aug 2023
“The contact owns a 2022 Chevrolet Bolt EV. The contact stated while attempting to charge the vehicle, the charging system failed to charge the vehicle adequately. The contact stated that shortly after beginning to charge the vehicle, the vehicle overheated after 30 minutes, and the charging light turned from blue to red. The contact then had to disconnect the charger. The vehicle was taken to the dealer who was unable to determine the cause of the failure with the charging unit. The vehicle had not been repaired. The manufacturer was made aware of the failure. The approximate failure mileage was 200.”Owner report · Electrical System · Aug 2023
“The contact owns a 2022 Chevrolet Bolt EV. The contact received notification of NHTSA Campaign Number: 21V650000 (Electrical System) however the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.”Owner report · Electrical System · Jun 2023
When filing, owners marked a crash in 3 of these complaints and injuries in 0 - self-reported to NHTSA, not verified accident statistics.
Recalls - 7 campaigns
General Motors, LLC (GM) is recalling certain 2020-2022 Chevrolet Bolt EV and 2022 Bolt EUV vehicles previously repaired under Recall 21V-650. The installation of advanced diagnostic software may have failed. As such, the high voltage battery could catch fire when charged to full or nearly full capacity.
Remedy: Owners are advised to take the following interim steps: Set the Target Charge Level feature in their vehicle to limit the charge level to 90%, charge their vehicle more frequently, avoid depleting the battery to 70 miles range remaining, park outside after charging, and do not charge the vehicle indoors overnight. Dealers will reinstall advanced diagnostic software, free of charge. Owner notification letters were mailed December 3, 2024. Owners may contact the Bolt EV Concierge Team at 1-833-382-4389. GM's number for this recall is N242470160.
General Motors, LLC (GM) is recalling certain 2020-2022 Chevrolet Bolt EV and 2022 Chevrolet Bolt EUV vehicles that were previously remedied under recall number 21V-650. The advanced diagnostic software may have been incorrectly installed and fail to detect defective battery modules, possibly resulting in a battery fire.
Remedy: Owners are advised to take the following interim steps: Set the Target Charge Level feature in their vehicle to limit the charge level to 90%, charge their vehicle more frequently, avoid depleting the battery to 70 miles range remaining, park outside after charging, and do not charge the vehicle indoors overnight. Dealers will reinstall the advanced diagnostic software, free of charge. Owner notification letters were mailed on August 1, 2024. Owners may contact the Bolt EV Concierge Team at 1-833-382-4389. GM's numbers for this recall are N242443000 and N242443002.
General Motors, LLC. (GM) is recalling certain 2022 Chevrolet Bolt EV and Bolt EUV vehicles. One of the two fasteners that secure the driver's frontal air bag to the steering wheel may be missing or improperly tightened.
Remedy: Dealers will inspect and replace as necessary, the driver-side air bag fasteners. If the fasteners cannot be tightened properly, the air bag assembly will be replaced. All repairs will be performed free of charge. Owner notification letters were mailed on July 29, 2021. Owners may contact Chevrolet customer service at 1-800-222-1020. GM's number for this recall is N212340860.
General Motors, LLC (GM) is recalling certain 2017-2023 Chevrolet Bolt EV vehicles. This recall includes certain vehicles previously repaired incorrectly under NHTSA recall number 22V-930. After a crash with seat belt pretensioner deployment, the pretensioner exhaust may ignite carpet fibers near the B-pillar, causing a fire.
Remedy: Dealers will inspect both front seat belt pretensioners and, if necessary, install metal foil at the carpet near the pretensioner exhaust. Certain vehicles will also need a pretensioner cover installed. Repairs will be performed free of charge. Owner notification letters were mailed January 24, 2024. These vehicles were previously recalled for this same issue under recall number 22V-930 and will need to have the new remedy performed. Owners may contact GM EV Concierge at 1-833-EVCHEVY (1-833-382-4389) (TTY 711 / 1-800-833-2438) or Customer Service at 1-800-222-1020. GM's number for this recall is N232421970.
General Motors, LLC (GM) is recalling certain 2017-2023 Chevrolet Bolt EV vehicles. After a crash with seat belt pretensioner deployment, the pretensioner exhaust may ignite carpet fibers near the B-pillar, causing a fire.
Remedy: Dealers will install metal foil at the carpet near the pretensioner exhaust, and install a pretensioner cover as necessary, free of charge. Owner notification letters were mailed between January 23, 2023 and April 25, 2023. Owners may contact Chevrolet customer service at 1-800-222-1020. GM's number for this recall is N222383790.
General Motors, LLC (GM) is recalling certain 2022-2023 Chevrolet Bolt EV vehicles. The instrument panel may be missing the perforation on the underside of the panel cover that allows the passenger-side air bag to deploy properly.
Remedy: Dealers will replace the instrument panel, free of charge. Owner notification letters were mailed December 21, 2023. Owners may contact Chevrolet customer service at 1-800-222-1020. GM's number for this recall is N232414710.
General Motors, LLC (GM) is recalling certain 2020-2022 Chevrolet Bolt EV and 2022 Chevrolet Bolt EUV vehicles. The high voltage battery could catch fire when charged to full or nearly full capacity.
Remedy: Owners are advised to take the following interim steps: Set the Target Charge Level feature in their vehicle to limit the charge level to 90%, charge their vehicle more frequently, avoid depleting the battery to 70 miles range remaining, park outside after charging, and do not charge the vehicle indoors overnight. Defective battery modules will be replaced by GM, free of charge. Owner notification letters were mailed on October 1, 2021 and June 23, 2023. Owners may contact the Bolt EV Concierge Team at 1-833-382-4389. This recall is an expansion of NHTSA recall 21V-560. GM's number for this recall is N212345940.
How other years compare
Check your exact Bolt by VIN
Recalls and equipment differ between individual vehicles. Decode your VIN to see what applies to yours.
Open VIN decoderFrequently asked questions
Is the 2022 Chevrolet Bolt reliable?
NHTSA has 59 owner complaints and 7 recall campaigns on record for the 2022 Chevrolet Bolt. The most complained-about area is electrical system (40% of complaints).
At what mileage do 2022 Chevrolet Bolt problems usually appear?
Half of the complaints that mention mileage were filed at 7,000 miles or less.
Does the 2022 Chevrolet Bolt have open recalls?
7 recall campaigns have been issued, the latest concerning electrical system:propulsion system:traction battery. Check your specific vehicle by VIN - recall repairs are free at franchised dealers.
Source: NHTSA recall campaigns and owner complaints (public domain). Counts reflect reports on file and are not a defect rate.