2012 BMW 535I: problems, recalls and reliability
1 recall and 54 owner complaints on record; the weakest area is fuel/propulsion system (23% of complaints).
Data updated weekly · latest recall Oct 2016
All counts are reports filed with NHTSA in the United States - US market only, not worldwide totals.
Common problems
Computed from 54 owner complaints filed with NHTSA for this exact model year.
“The contact owns a 2012 BMW 535I. The contact stated while driving at approximately 65 MPH, the engine temperature and "Pull Over - Stop Vehicle" warning lights were illuminated. The contact pulled over and let the vehicle cool down and drove to an independent mechanic. The vehicle was diagnosed, and it was determined that the water pump needed to be replaced. The mechanic advised the contact that there was an active recall, NHTSA Campaign Number: 24V608000 (Engine and Engine Cooling, Electrical System); however, the VIN was not included in the recall. The vehicle was not repaired. The manufacturer was informed of the failure. The failure mileage was approximately 127,000.”Owner report · Engine And Engine Cooling · Oct 2024
“Confirmed by a Certified BMW repair center. Failure of Vanos Camshaft Gear Bolts. Recall has been issued for all 5 series models (and beyond) up to 2011, but does not include 2012 (5 series,) as it should. The Recall needs to be extended to include 2012 - 5 series models as failure of these bolts will cause immediate engine failure and could result in catastrophic crash, especially if driving at high speeds. I have contacted BMW of North America and they will not extend the recall until formal complaints, such as this, are received. My Issue with the Vanos Camshaft Bolts is currently being repaired (out of pocket) and I will share my invoice once received.”Owner report · Engine · Jan 2024
“The headlights on the BMW 535 collect excessive amounts of condensation. If the condensation builds up, then the light does not function properly. The main safety concern is the malfunction of the turn signal. It will function in the rear of the vehicle but does not light up on the front in the affected headlight housing. Review of this problem on-line shows that this has occurred in many BMW vehicles and BMW also has issued a service bulletin for this problem (SI B63 05 16). As widespread as this problem is, I would think there would be a required recall for this service.”Owner report · Exterior Lighting · Jan 2023
Show 7 more owner reports
“The front lights - water gets in impact visibility. The only repair is to replace the entire unit which is $2k per light. There is not other options. The adaptive warning sign does not go away due to this water.”Owner report · Exterior Lighting · Jul 2022
“Driver seatbelt fails to engage with latch. Latch does not positively lock when inserted. Safety risk is obvious and has rendered the car undrivable. This just happened and has not been inspected by dealer. I personally looked at it and compared with other belt points. to me, it looks like the small metal clip failed.”Owner report · Seat Belts · Apr 2022
“While driving heard a loud noise and oil start pouring out the bottom of the car.. After getting my Vehicle looked at BMW dealership informed me that the drive shaft had broken and fell in the engine and caused a hole in the engine and damaging the oil pan also”Owner report · Power Train · Apr 2022
“Based on research it appears BMW has a long history of issues and even a recall on select years around the passenger seat sensor detector becoming faulty and impacting the ability of the air bags to deploy in a collision. This seems to a critical issue since it could result in serious injury to the passenger in the event of a collision.”Owner report · Seats · Oct 2021
“While driving car stalled, dropped speed and engine warning light came on. Fuel pump was needed. Had to have car towed obtained a rental for 11 days. Fuel pump out of stock. Immediately after fuel pump was replaced less than two weeks the thermostat had to be replaced. Another tow and another rental. I need to be compensated for stress aggravation and loss of use. Repairs and car rental and tow cost over $3500”Owner report · Fuel/Propulsion System · Sep 2021
“The contact owns a 2012 BMW 535i. The contact stated that the power train warning message was displayed. The vehicle was diagnosed but not repaired. The manufacturer was not informed of the failure. The failure mileage was approximately 70,000.”Owner report · Power Train · Jun 2021
“The headlight get condensation inside which reduces intensity of head light. This condensation has now corrupted the adaptive headlight control module which made the turn signal not work. The design of the head light mounting makes for a very expensive repair and/or replacement by have to remove bumper just to get to headlight. 1. Condensation reduces intensity of headlights 2. Moisture corroded adaptive headlight controller module that also made turn signal not work. 3. Very complicated access to headlight to repair (very expensive)”Owner report · Visibility/Wiper · Feb 2021
Recalls - 1 campaign
BMW of North America, LLC (BMW) is recalling certain model year 2007-2011 BMW X5 3.0si, X5 4.8i, X5 M, X5 xDrive30i, X5 xDrive35i, X5 xDrive48i and X5 xDrive50i, 2008-2011 X6 x Drive35i, X6 xDrive50i and X6 M, 2010-2011 X6 ActiveHybrid, 535i xDrive Gran Turismo, 535i Gran Turismo, 550i xDrive Gran Turismo and 550i Gran Turismo, 2011-2012 528i, 535i, 535i xDrive, 550i and 550i xDrive and 2012 535i ActiveHybrid, 640i Convertible, 650i Convertible, 650i xDrive Convertible, 650i Coupe and 650i Coupe xDrive vehicles. The affected vehicles have in-tank fuel pumps that may have insufficiently crimped wire contacts.
Remedy: BMW will notify owners, and dealers will replace the fuel pump module, free of charge. The recall began February 2017. Owners may contact BMW customer service at 1-800-525-7417.
Specifications
Factory options offered for the 2012 model year, decoded from the NHTSA vPIC database. Individual vehicles have one of each.
How other years compare
Check your exact 535I by VIN
Recalls and equipment differ between individual vehicles. Decode your VIN to see what applies to yours.
Open VIN decoderFrequently asked questions
Is the 2012 BMW 535I reliable?
NHTSA has 54 owner complaints and 1 recall campaign on record for the 2012 BMW 535I. The most complained-about area is fuel/propulsion system (23% of complaints).
At what mileage do 2012 BMW 535I problems usually appear?
Half of the complaints that mention mileage were filed at 70,500 miles or less.
Does the 2012 BMW 535I have open recalls?
1 recall campaign has been issued, the latest concerning fuel system, gasoline:delivery:fuel pump. Check your specific vehicle by VIN - recall repairs are free at franchised dealers.
Source: NHTSA recall campaigns and owner complaints (public domain). Counts reflect reports on file and are not a defect rate.